Management
Procedures.
Breeder
Nipples with
LitterGard
Cups
Nipple Height Adjustments
10
(254mm)
DAY 1 ONLY
DAY 1 ONLY
MALES - Set
nipple at eye level.
FEMALES - Set
nipple at eye level.
DAY 2 - END
DAY 2 - END
MALES - Set nipple
at 45 degrees
above eye level.
FEMALES - Set
nipple at 45 degrees
above eye level.
9
(229mm)
8
(203mm)
7
(178mm)
First Day – Set nipple height to where the birds, in normal standing position, are looking directly at the
nipple. Leave at this height until the following morning. At this time, raise drinkers to where the birds
are pecking the nipple at a 45 degree angle. Continue this angle during the remainder of production.
Breeder
Nipples with
LitterGard
Cups
IM-030-03
Nipple Height Adjustments
11
(279mm)
10
(254mm)
DAY 1 ONLY
DAY 1 ONLY
MALES - Set
nipple at eye level.
FEMALES - Set
nipple at eye level.
9
(229mm)
8
DAY 2 - END
DAY 2 - END
MALES - Set nipple
at 45 degrees
above eye level.
FEMALES - Set
nipple at 45 degrees
above eye level.
(203mm)
7
(178mm)
First Day – Set nipple height to where the birds, in normal standing position, are looking directly at the
nipple. Leave at this height until the following morning. At this time, raise drinkers to where the birds
are pecking the nipple at a 45 degree angle. Continue this angle during the remainder of production.
6
(152mm)
Water Column Pressure
IM-030-03
11
(279mm)
10
(254mm)
DAY 1 ONLY
DAY 1 ONLY
MALES - Set
nipple at eye level.
FEMALES - Set
nipple at eye level.
9
(229mm)
8
DAY 2 - END
DAY 2 - END
MALES - Set nipple
at 45 degrees
above eye level.
FEMALES - Set
nipple at 45 degrees
above eye level.
(203mm)
7
(178mm)
First Day – Set nipple height to where the birds, in normal standing position, are looking directly at the
nipple. Leave at this height until the following morning. At this time, raise drinkers to where the birds
are pecking the nipple at a 45 degree angle. Continue this angle during the remainder of production.
Water Column Pressure
8 inches
(203mm)
Adjust water
column pressure
by turning knob.
Set water column pressure at 8
inches (203mm) to achieve an
average of 40-50 ml/min. Exceeding
this setting will increase water flow
and the possibility of wet litter;
operating at less than 6 inches
(152mm) could lead to decreased
production levels. Depending upon
weather conditions and breed of
bird, water consumption will vary. In
general, water level should be kept
as high as possible without wetting
the litter.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
6
(152mm)
5
(127mm)
4
(102mm)
8 inches
(203mm)
Adjust water
column pressure
by turning knob.
Set water column pressure at 8
inches (203mm) to achieve an
average of 40-50 ml/min. Exceeding
this setting will increase water flow
and the possibility of wet litter;
operating at less than 6 inches
(152mm) could lead to decreased
production levels. Depending upon
weather conditions and breed of
bird, water consumption will vary. In
general, water level should be kept
as high as possible without wetting
the litter.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
5
(127mm)
4
(102mm)
8 inches
(203mm)
SET ON
TOP OF
REGULATOR
Breeder
Nipples with
LitterGard
Cups
Nipple Height Adjustments
SET ON
TOP OF
REGULATOR
BREEDERS
Management
Procedures.
Adjust water
column pressure
by turning knob.
Set water column pressure at 8
inches (203mm) to achieve an
average of 40-50 ml/min. Exceeding
this setting will increase water flow
and the possibility of wet litter;
operating at less than 6 inches
(152mm) could lead to decreased
production levels. Depending upon
weather conditions and breed of
bird, water consumption will vary. In
general, water level should be kept
as high as possible without wetting
the litter.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
5
(127mm)
4
(102mm)
SET ON
TOP OF
REGULATOR
Management
Procedures.
6
(152mm)
Water Column Pressure
BREEDERS
BREEDERS
IM-030-03
Management
Procedures.
FeatherSoft
Nipples w/out
LitterGard
Cups
Set nipples at eye
level with the birds.
Raise nipple just
above eye level.
DAY 3 - END
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
Water Column Pressure
FeatherSoft
Nipples w/out
LitterGard
Cups
Raise nipple just
above eye level.
DAY 3
DAY 3 - END
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
(254mm)
9
(229mm)
8
wk 4
DAY 2
10
(203mm)
wk 3
DAY 1
Set nipples at eye
level with the birds.
(178mm)
(152mm)
7
Management
Procedures.
FeatherSoft
Nipples w/out
LitterGard
Cups
wk 5 wk 6-end
wk 5 wk 6-end
Raise nipple just
above eye level.
8
(203mm)
wk 4
wk 4
Maintain nipple at
45 degrees above
Raise nipple to 45
degrees above
eye level.
9
(229mm)
DAY 3 - END
DAY 3
6
10
(254mm)
DAY 2
DAY 1
Set nipples at eye
level with the birds.
7
wk 3
wk 3
(178mm)
Water Column Pressure
6
wk 1
wk 1
5
(127mm)
4
Adjust water
column pressure
by turning knob.
(102mm)
5
Set according
to age of bird.
wk 1
wk 2
wk 2
(152mm)
Set according
to age of bird.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
BROILERS
IM-030-01
Nipple Height Adjustments
11
(279mm)
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
(229mm)
(203mm)
(178mm)
(152mm)
5
Set according
to age of bird.
wk 1
Water Column Pressure
9
6
11
(279mm)
wk 2
Nipple Height Adjustments
wk 5 wk 6-end
IM-030-01
(254mm)
7
wk 2
Management
Procedures.
10
8
wk 3
DAY 3
wk 6-end
DAY 2
wk 5
DAY 1
wk 4
Nipple Height Adjustments
BROILERS
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
BROILERS
IM-030-01
Management
Procedures.
FeatherSoft
Nipples with
LitterGard
Cups
10
Nipple Height Adjustments
(254mm)
DAY 2
Set nipples at eye
level with the birds.
Raise nipple just
above eye level.
DAY 3
DAY 3 - END
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
FeatherSoft
Nipples with
LitterGard
Cups
DAY 2
Raise nipple just
above eye level.
(229mm)
DAY 3
DAY 3 - END
Raise nipple to 45
degrees above
eye level.
(203mm)
Maintain nipple at
45 degrees above
eye level.
(152mm)
10
(254mm)
DAY 2
DAY 3 - END
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
9
(229mm)
8
(203mm)
7
(178mm)
6
days 1 - 3
(152mm)
Set according
to age of bird.
5
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
days 1 - 3
Raise nipple just
above eye level.
DAY 3
days 4 - end
Set nipples at eye
level with the birds.
Water Column Pressure
Set according
to age of bird.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
7
(178mm)
6
11
IM-030-01
BROILERS
8
(279mm)
Nipple Height Adjustments
DAY 1
9
days 4 - end
Water Column Pressure
5
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
Set according
to age of bird.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
7
(178mm)
(152mm)
(254mm)
DAY 1
Set nipples at eye
level with the birds.
(203mm)
6
11
10
Nipple Height Adjustments
FeatherSoft
Nipples with
LitterGard
Cups
8
(279mm)
IM-030-01
Management
Procedures.
(229mm)
days 1 - 3
Management
Procedures.
9
days 4 - end
DAY 1
Water Column Pressure
BROILERS
5
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
BROILERS
IM-030-01
Management
Procedures.
FeatherSoft
Nipples w/out
LitterGard
Cups
Set nipples at eye
level with the birds.
Raise nipple just
above eye level.
DAY 3 - OUT
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
Water Column Pressure
FeatherSoft
Nipples w/out
LitterGard
Cups
Raise nipple just
above eye level.
DAY 3
DAY 3 - OUT
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
(254mm)
9
wk 5
DAY 2
(229mm)
wk 4
DAY 1
Set nipples at eye
level with the birds.
10
(203mm)
wk 3
Nipple Height Adjustments
(178mm)
(152mm)
8
7
Management
Procedures.
FeatherSoft
Nipples w/out
LitterGard
Cups
wk 5 wk 6-out
wk 5 wk 6-end
Raise nipple just
above eye level.
8
(203mm)
wk 4
wk 4
Maintain nipple at
45 degrees above
Raise nipple to 45
degrees above
eye level.
9
(229mm)
DAY 3 - OUT
DAY 3
6
10
(254mm)
DAY 2
DAY 1
Set nipples at eye
level with the birds.
wk 3
wk 3
7
(178mm)
Water Column Pressure
6
wk 1
wk 1
5
(127mm)
4
Adjust water
column pressure
by turning knob.
(102mm)
5
Set according
to age of bird.
wk 1
wk 2
wk 2
(152mm)
Set according
to age of bird.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
PULLETS
IM-030-01
Nipple Height Adjustments
11
(279mm)
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
(229mm)
(203mm)
(178mm)
(152mm)
5
Set according
to age of bird.
wk 1
Water Column Pressure
9
6
11
(279mm)
wk 2
wk 6-out
IM-030-02
(254mm)
7
wk 2
Management
Procedures.
10
8
wk 3
DAY 3
wk 6-out
DAY 2
wk 5
DAY 1
wk 4
Nipple Height Adjustments
PULLETS
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
PULLETS
IM-030-02
Management
Procedures.
FeatherSoft
Nipples with
LitterGard
Cups
Set nipples at eye
level with the birds.
Raise nipple just
above eye level.
DAY 3 - OUT
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
Water Column Pressure
DAY 3
DAY 3 - OUT
Raise nipple to 45
degrees above
eye level.
Maintain nipple at
45 degrees above
eye level.
Water Column Pressure
FeatherSoft
Nipples with
LitterGard
Cups
9
(229mm)
8
days 4 - out
Maintain nipple at
45 degrees above
eye level.
(203mm)
7
(178mm)
6
days 1 - 3
(152mm)
Set according
to age of bird.
5
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
5
Set according
to age of bird.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
(152mm)
7
6
10
(254mm)
DAY 3 - OUT
Raise nipple to 45
degrees above
eye level.
SET ON
TOP OF
REGULATOR
PULLETS
IM-030-02
Raise nipple just
above eye level.
DAY 3
(178mm)
8
11
DAY 2
DAY 1
Set nipples at eye
level with the birds.
Water Column Pressure
(203mm)
(279mm)
Nipple Height Adjustments
9
(229mm)
wk 1
Management
Procedures.
(254mm)
wk 5
Raise nipple just
above eye level.
wk 4
DAY 2
10
wk 3
DAY 1
Set nipples at eye
level with the birds.
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
Set according
to age of bird.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
9
(229mm)
(203mm)
(178mm)
6
11
(279mm)
wk 2
Nipple Height Adjustments
wk 6-out
IM-030-02
wk 2
FeatherSoft
Nipples with
LitterGard
Cups
(254mm)
7
(152mm)
5
wk 1
Management
Procedures.
10
8
wk 3
DAY 3
wk 6-out
DAY 2
wk 5
DAY 1
wk 4
Nipple Height Adjustments
PULLETS
(127mm)
4
(102mm)
Adjust water
column pressure
by turning knob.
NOTE: Water consumption can be affected by climate conditions and nipple height.
Therefore, it is good practice to pay close attention to litter conditions and make
adjustments accordingly. If floors are wet the water column may be too high or the
drinker line is too low. If floors are dry the water column may be too low.
Phone
Toll-Free Fax
www.lubingusa.com
[email protected]
423 709.1000 866 289.3237
SET ON
TOP OF
REGULATOR
PULLETS
IM-030-02