Piper Cub
Models PA-15 and PA-17
Parts Catalog
Toll Free Sales: 1-888-433-5433
AIRCRAFT CORPORATION
2500 Himalaya Road • Aurora, Colorado • 80011-8156
Info Phone........................................................ 303-375-8882
Fax.....................................800-457-7811 or 303-375-8888
Email........................................................... [email protected]
Website......................................................www.univair.com
15PM
INTRODUCTION
This Parts Catalog covers both the Piper VAGABOND (Model PA-15) and the VAGABOND TRAINER (Model
PA-17) herein after only referred to as Model PA-15 or PA-17.
Due to the extreme interchangeability between the above named Aircraft, only one Parts Catalog has
been prepared for use in the selection of spare parts for both Aircraft.
The main points to keep in mind while using this Parts Catalog are: UNLESS THE MODEL IS GIVEN AFTER
THE PARTS NAME, THE PART IS FOR USE ON BOTH MODELS PA-15 AND PA-17. Should the quantity used
PER SHIP not be the same on both models, then the part is repeated, allowing the correct quantity for
each model to be shown. PER SHIP column represents total requirement for entire airplane.
It will also be noted that no illustrated drawings have been furnished for this Parts Catalog, therefore,
selection of parts must be made by Part Name only. It is not believed that this will hamper rapid selection
of parts, as very appropriate names were given the parts, indicating their location on the airplane.
This Parts Catalog has been divided into eight main sections, and are identified and found herein, as
follows:
SECTION
PAGE NUMBER
Wing................................................................................................................................................................................................. 1
Fuselage......................................................................................................................................................................................... 2
Cockpit............................................................................................................................................................................................ 3
Chassis and Brake....................................................................................................................................................................... 3
Control............................................................................................................................................................................................ 5
Power Plant................................................................................................................................................................................... 7
Fuel System................................................................................................................................................................................... 8
Accessories and Miscellaneous.............................................................................................................................................. 9
This manual is a direct copy of the original.
We assume no responsibility for the contents.
Univair Aircraft Corporation
I
GENERAL INFORMATION
Explanation of Abbreviations Used Herein
Ail. = Aileron
Brkt. = Bracket
Inbd. = Inboard
Inst. = Installation
F. = Front
Frt. = Front
Ftg. = Fitting
L.E. = Leading Edge
LH = Left Hand
L.G. = Landing Gear
Outbd. = Outboard
R. = Rear
RH = Right Hand
S. = Strut
Sht. = Sheet
How To Order Parts
In ordering parts for your Piper Airplanes observe the following instructions which will aid in shipping the correct parts required with a minimum of
errors and delay:
1. PLACE YOUR ORDER WITH THE DISTRIBUTOR FOR YOUR TERRITORY. If he does not have the required parts, he will promptly order from the factory. In
the majority of cases, parts are available only through your distributor, and it is necessary that we forward your order to your distributor to be filled.
Considerable time will be saved by complying with these instructions.
2. Always specify MODEL and SERIAL NUMBER of your airplane.
3. Advise us of the PART NUMBER, NAME, TYPE and QUANTITY required.
4. Specify METHOD OF SHIPMENT – Freight, Express, Air Express, Air Mail, or Parcel Post. Most parts are shipped by Parcel Post or Express, but where
the nature of shipment requires it we reserve the right to ship via the most suitable method.
Shortages
All shipments are checked and rechecked before leaving our Shipping Department to prevent errors and shortages. A packing slip is enclosed with the
shipment and claims for shortages must be made within three days after receipt.
Returned Goods
No material should be returned to us without first securing our written permission. Material sent in without notice will be held at the owners risk for
thirty (30) days and we will then dispose of it as we see fit. A returned good notice must be filled out for all material to be returned. Transportation
charges must be PREPAID on returned goods or the shipment will be refused.
Transportation Liabilities
The Piper Aircraft Corporation does not hold itself liable for damages to parts in transit from the factory. If a shipment is received in a damaged condition,
have the delivery man or Transportation Company make a notation of the damage and file your claim with the carrier. In case of concealed damage, do
not attempt to remove from shipping container, or endeavor to repair, but call carrier and have Claim Agent inspect the damage before filing your claim
with the Carrier.
II
PIPER AIRCRAFT CORPORATION
LOCK HAVEN, PENNA.
CHANGE NO.
PAGE NO.
Page No. 1
Corrections to Piper Cub Vagabond (Models PA-15 and PA-17) Parts Catalog
Date: Feb. 1,1949
FUSELAGE SECTION
1
2
Part 12761-00 COVER – Inspection superseded by part 12761-02 COVER – Inspection.
COCKPIT SECTION
2
3
Part 451 335 BELT ASSEMBLY – Safety superseded by part 451 336 BELT ASSEMBLY – Safety.
3
3
Following items added to be inserted after part 11484-00 DECAL – Maneuverability (PA-17):
11432-05 CHANNEL – Weather Strip – Window – Top Left – 1 per ship
11432-07 CHANNEL – Weatherstrip – Window – Side Front Left – 1 per ship
11432-06 CHANNEL – Weatherstrip – Window – Bottom Left – 1 per ship
11432-08 CHANNEL – Weatherstrip – Window Side Rear Left – 1 per ship
4
3
A single asterisk (*) to be inserted preceding the part number of part 450 628 COMPASS, and the following note
placed at bottom of page 3: *Refer to correction sheet page number 1, change number 5.
5
Following replaces item marked in accordance with change number 4 (no Parts Catalog change required):
450 625 COMPASS – (3½” mounting) – 1 per ship (used on PA-15 airplanes serial numbers 15-1 to 15-387
included, and on PA-17 airplanes serial numbers 17-1 to 17-173 included)
450 628 COMPASS – (25⁄8” mounting) – 1 per ship (used on PA-15 airplanes serial numbers15-388 and up, and on
PA-17 airplanes 17-174 and up)
CHASSIS AND BRAKE SECTION
6
4
Three (***) asterisks to be inserted, preceding nomenclature of part 11803-00 STRUT ASSEMBLY – Short Shock
(Lower).
7
4
Following item to be added, indented under part 11805-00 STRUT ASSEMBLY – Shock (Complete):
***81232-30 DISC – Leather – 4 per ship
8
4
Following item to be added, indented under Part 451 702 BRAKE SHOE ASSEMBLY:
750 893 SHIELD – Expender Tube Protector – 12 per ship
CONTROL SECTION
9
5
Following are superseding part numbers:
42585-02 superseded by 40471-05
42585-05 superseded by 40471-07
42585-03 superseded by 40471-08
42585-06 superseded by 40471-06
42585-04 superseded by 40471-04
42585-07 superseded by 40471-03
III
42585-08 superseded by 40471-02
42585-09 superseded by 40471-02
PIPER AIRCRAFT CORPORATION
LOCK HAVEN, PENNA.
CHANGE NO.
PAGE NO.
Page No. 2
Corrections to Piper Cub Vagabond (Models PA-15 and PA-17) Parts Catalog
Date: Feb. 1,1949
CONTROL SECTION (CONT’D)
10
5
Following parts to be deleted:
42585-10 AILERON REAR SECTION – Left Hand
42585-11 AILERON REAR SECTION – Right Hand
POWER PLANT SECTION
11
8
Part 12761-00 COVER – Inspection – Top cowl superseded by part 12761-02 COVER – Inspection – Top Cowl
12
8
Following part to be added, indented under parts 11831-00 STACK & MUFFLER ASSEMBLY – Exhaust Left (PA-17),
and 11709-00 STACK & MUFFLER ASSEMBLY – Exhaust Left (PA-15): 71053-06 MUFFLER ASSEMBLY (Less Stack) – 1
per ship. (NOTE: Requires welding for attachment to stack.)
FUEL SYSTEM SECTION
13
8
Delete PA-17 reference from part 460 661 ELBOW – Gas Shut-off to Tank.
14
9
Following item should be added, inserted after part 460 665 – NUT – 1⁄8 Inverted – for Primer Line:
460 656 NIPPLE – Gas Shut-off to Elbow Connection (to Tank) – 1 per ship
15
8 and 9
16
A single asterisk (*) to be inserted preceding the part numbers of the following parts, and the following note
placed at the bottom of the appropriate pages: *Refer to correction sheet, page number 2, change number 15.
460 661 ELBOW – Gas Shut-off to Tank
74032-00 VALVE – Fuel
10143-77 LINE – Fuel – Valve to Fuel Strainer
460 656 NIPPLE – Gas Shut-off to Elbow Connection (to Tank)
The following replaces those items marked in accordance with change number 15 (no Parts Catalog change
required):
460 661 øELBOW – Gas Shut-off to Tank – 1 per ship
492 014 øøVALVE – Fuel – 1 per ship
460 654 øELBOW – Gas Shut-off to Tank – 1 per ship
460 655 øNIPPLE – Shut-off to Elbow Connection (to Tank) – 1 per ship
10143-77 øLINE – Fuel Valve to Fuel Strainer – 1 per ship
11987-02 øøTUBE – Shut-off to Elbow Connection (to Tank) – 1 per ship
11986-00 øLINE – Fuel Valve to Fuel Strainer – 1 per ship
74032-00 øVALVE – Fuel – 1 per ship
ø
Used on PA-15 airplanes serial numbers 15-1 to 15-387 included, and on PA-17 airplanes serial numbers 17-1 to
17-211 included.
øø
Used on PA-15 airplanes serial numbers 15-388 and up, and on PA-17 airplanes serial numbers 17-212 and up.
IV
WING • MODELS PA-15 AND PA-17
NOTICE: All items numbered from wing butt outward
Wing
PARTPER
NUMBER
SHIP
11528-00
11528-01
11520-000UR
1
1
1
11520-001UR
1
U10291-000
4
U14291-000
U14291-001
U14401-003
U14401-004
U14401-005
U14401-006
U14411-002
U14411-003
U14411-004
U10912-006
U10921-000
U11580-000
U12252-002
U12252-003
1
1
2
2
2
2
2
2
2
6
6
1
12
14
U12252-004
U12252-005
4
2
U12252-008
U14541-000
U14271-000
U14461-000
80022-031
4
12
4
4
4
U86102-019
-86102-035
U82141-000
U453-126
U10221-000
2
2
4
2
20
NOMENCLATURE
Wing Panel – Covered and Doped – LH (Less Aileron)
Wing Panel – Covered and Doped – RH (Less Aileron)
Wing Panel – Uncovered and Doped – LH (Less
Aileron)
Wing Panel – Uncovered and Doped – RH (Less
Aileron)
Angle – Rear Spar (Inboard and Outboard Aileron
Hinge Bracket)
Angle – Center Aileron Hinge Bracket – LH
Angle – Center Aileron Hinge Bracket – RH
Angle – Front Spar (#2 Drag Strut)
Angle – Front Spar (#3 Drag Strut)
Angle – Front Spar (#5 Drag Strut)
Angle – Front Spar (#1 Drag Strut)
Angle – Rear Spar (#2 Drag Strut)
Angle – Rear Spar (#3 Drag Strut)
Angle – Rear Spar (#5 Drag Strut)
Bracket Assembly – Aileron Hinges
Block – Aileron hinge bearing
Bracket – Airspeed Tube – LH
Braces Wing Channel 8½” (at Butt Rib)
Braces Wing Channel 16” (at Butt Rib and Rear Wing
Bow)
Braces – Channel 17” (Wing Tip Bow to Spar)
Braces – Wing Channel 11” (at Wing Tip Bow – Rear
Short)
Braces – Wing Channel 13¾” (at Trailing Edge)
Braces – Aileron False Spar
Block – Rear Spar Lift Strut Fitting Filler
Block – Front Spar Lift Strut Fitting Filler
Bushings – Spar Butt Fitting – F.R. – and #1 Drag Strut
– Rear
Bushings – Lift Strut Fitting Bolt at Wing
Bushings – Aileron Pulley Bracket
Bolt – Lift Strut Fork
Bow – Wing Tip
Clevis – Tie Rod
1
-10870-003
1
-10870-004
1
-10870-004
2
U40123-049
U11527-000
U10931-002
U12761-002
U13072-005
U15472-002
U15482-000
U15482-001
U15723-000
U15723-001
U10161-004
U10161-005
U10171-004
U10171-003
U10401-000
U14161-000
U14182-000
U14192-000
U16551-000
U16561-000
U16601-000
U16611-000
U41421-000
U14261-002
U11281-005
U1600-01
U11523-000
U11524-000
U11524-001
U11525-000
U11659-000
U11526-000
U11526-001
U40071-000
U40081-000
1
1
6
6
2
2
1
1
1
1
4
4
4
4
4
4
4
4
2
2
2
2
2
2
4
4
2
1
1
1
1
1
1
12
11
Cable – Aileron – LH – to Lower Aileron Horn on
Struts (PA-15)
Cable – Aileron – RH – to Lower Aileron Horn on
Struts (PA-15)
Cable – Aileron – to Lower Aileron Horn on Struts
(PA-17)
Cable – Aileron – RH in Wing
Cable – Aileron – LH in Wing
Clamp – Aileron Hinge Bracket False Spar
Cover Assembly – Inspection (Round)
Cover – Leading Edge (Outboard)
Cover – Leading Edge (Inboard)
Cover – Leading Edge Center LH
Cover – Leading Edge Center RH
Cover – Leading Edge Wing Tip LH
Cover – Leading Edge Wing Tip RH
Fitting – Drag Wire Pull #2 Drag Strut
Fitting – Drag Wire Pull #3 Drag Strut
Fitting – Drag Wire Pull
Fitting – Drag Wire Pull #4 Drag Strut
Fitting – Front Spar Butt Hinge
Fitting – Rear Spar Butt Hinge
Fitting – Rear Spar Lift Strut
Fitting – Front Spar Lift Strut
Fitting – Front Spar Bow – Rear
Fitting – Front Spar Bow – Front
Fitting – Rear Spar Bow – Front
Fitting – Rear Spar Bow – Rear
Fitting – Aileron Pulley Bracket Attachment (Lower)
Fitting – Aileron Pulley Bracket Attachment (Upper)
Fork – Lift Strut (Original)
Fork – Lift Strut (Heavy Duty ⅝”)
Fairing – Wing Root – Upper (Front or Rear)
Fairing – Wing Root – Lower (Rear Left)
Fairing – Wing Root – Lower (Rear Right)
Fairing – Wing Root – Lower (Front Left)
Fairing – Wing Root – Lower (Front Right)
Fairing – Wing Root – Front – LH (Leading Edge)
Fairing – Wing Root – Front – RH (Leading Edge)
Fairlead – Cable (Less Snap Ring)
Ring – Cable Fairlead Snap
WING • FUSELAGE • MODELS PA-15 AND PA-17
NOTICE: All items numbered from wing butt outward
13171-000
4
U85012-078
5
80122-051
7
U80122-053
58
U41291-000
4
187-030
12”
U10201-000
20
U10151-000
20
U10531-000
1
U10531-001
1
U11151-000
2
-11521-000
2
U40991-000
4
U1206-00
1
U1206-01
1
U1228-02
1
U1228-03
1
U1228-05
2
U1227-03
2
U1200-02
12
U1202-00
1
U1202-01
1
U1207-00
8
U1208-00
2
U1233-00
2
U1200-05
2
U1216-00
1
U1216-01
1
-750-454
U15742-000
2
U15761-000
4
U11515-002
1
U11515-003
1
U11516-002
1
U11516-003
1
U15562-002
1
U15562-003
1
U15572-000
1
U15572-001
1
U15631-002
2
U15631-003
2
Gusset – Wing False Spar
Grommet – Inspection Cover (Round)
Grommet – 1½” OD Pyralin at Butt
Grommet – Drain – Small
Housing – Wing Aileron Cable Pulley
Hose – Rubber Airspeed – 4”
Nipple – Tie Rod
Plate – Lock (Drag Strut Bolt)
Plate – Fabric Former LH (#5 Drag Strut)
Plate – Fabric Former RH (#5 Drag Strut)
Plate – Wing Rib Fair Lead Bracket “U”
Plate – False Spar Reinforcement
Pulley – Aileron Cable (In Wing)
Rib – Aileron Outboard LH #10
Rib – Aileron Outboard RH #10
Rib – Aileron Inboard LH
Rib – Aileron Inboard RH
Rib – Full #2
Rib – Full #1
Rib – Nose
Rib – Tip LH #11
Rib – Tip RH #11
Rib – Three Quarter #5, 6, 8, 9
Rib – Three Quarter #7
Rib – Three Quarter #4
Rib – Wing Nose (special) #4
Rib – Wing Tip Nose LH
Rib – Wing Tip Nose RH
Rib – Repair Kit
Reinforcement – Wing Leading Edge
Reinforcement – Pyralin at Lift Strut Fittings
Spar – Rear LH
Spar – Rear RH
Spar – Front LH
Spar – Front RH
Spar – False (Inboard Section) LH
Spar – False (Inboard Section) RH
Spar – False (Outboard Section) LH
Spar – False (Outboard Section) RH
Spacers – Lift Strut Fitting – Front Spar
Spacers – Lift Strut Fitting – Rear Spar
U85556-002
U85557-002
U11281-005
U52745-000
U14222-000
U14222-002
U14232-002
15641-00
U10112-007
U16462-000
U16472-000
13541-13
11582-00
CSI-1020-096
U80122-011
U81102-003
U14941-006
U14941-007
2
2
4
1
2
2
2
20
2
2
2
1
1
2
2
20
8
4
Strut – Front Lift
Strut – Rear Lift
Fork – Lift Strut (Original)
Strut – Door Catch
Strut – Drag #4
Strut – Drag #2
Strut – Drag #1
Plug – Drag Strut
Tube – Drag Strut Diagonal #3
Tube – “N” Brace Upper #3
Tube – “N” Brace Lower #3
Tubing – Airspeed LH
Tube – Pitot – Airspeed
Trailing Edge – Wing
Washers (Lift Strut Pulley Bracket)
Washers – Square Tie Rod Clevis
Wires – Wing Drag #l and #2 Bay
Wires – Wing Drag #3 Bay
Fuselage
PARTPER
NUMBER
SHIP
750-974
1
11576-04
1
750-915
1
11604-02
1
11604-03
1
11605-00
1
U12761-002
6
11558-00
1
11558-01
1
21642-07
1
21642-08
1
U11821-000
1
U11821-001
1
11823-00
1
11823-01
1
-20291-000
2
2
NOMENCLATURE
Fuselage Frame Assembly – Covered and Doped – Less
Seat, Floors and Door
Fuselage Frame Assembly – Uncovered – Less Door
Fuselage Motor Mount Section
Cowl – Fuselage Left Side
Cowl – Fuselage Right Side
Door Assembly – See Cockpit Section
Firewall Assembly
Cover – Inspection (Round)
Fitting Assembly – Landing Gear Front LH
Fitting Assembly – Landing Gear Front RH
Fitting – Landing Gear and Lift Strut RH
Fitting – Landing Gear and Lift Strut LH
Fitting – Fuselage Rear Wing Hinge LH
Fitting – Fuselage Rear Wing Hinge RH
Fitting – Front Wing Hinge LH
Fitting – Front Wing Hinge RH
Fitting – Fuselage Engine Mount – Upper
FUSELAGE • COCKPIT • CHASSIS AND BRAKE • MODELS PA-15 AND PA-17
20301-000
2
L1027-01
1
U20631-000
1
11665-00
1
U80541-002
2
MS35822-13D-20 1
11629-00
1
21211-00
21621-16
1
4
80122-007
U82461-000
4
1
Fitting – Fuselage Engine Mount – Lower
Fitting – Tail Skid Rear
Fitting – Tail Skid Front “U”
Fairing – Fin Leading Edge
Frame – Inspection Window – at Tail
Hinge – Fuselage Door
Plate – Fuselage Cover – Bottom Rear of Fuselage
Cowl Sides
Support – Stabilizer Rear
Stringers – Fuselage Fairing – 47¾” Long (cut tapered
end for 41” length)
Washer – Fuselage Cowl
Window – Inspection (at Tail)
11653-09
1Hinge
412-012
1
Door Handle and Latch Assembly
-10280-000
1
Door Strut Catch
-11714-000
2
Decal – Vagabond
-11919-000
2
Decal – Trainer
11597-00
1Floorboard
U10293-000
2
Grommet – Tail Inspection Panel
450-604
1
Gauge – Oil Temp and Pressure (PA-15)
450-621
1
Gauge – Oil Temp and Pressure (PA-17)
-11882-000
2
Holder – Control Stick (PA-17)
-187-030
12”
Hose – Rubber 4” Long
10483-02
1
Indicator Assembly – Airspeed
10980-02
1
Plate – Door Latch Striker
11588-00
1
Panel – Baggage Compartment
-11630-000
1
Panel – Instrument
11640-00
1
Plate – Door Latch Striker
-15302-002
1
Switch – Ignition
U1713-N340
1
Tachometer Shaft with Core
750-909
1Core
13541-03
1
Tubing – Airspeed
13541-04
2
4” Long
11570-00
1
Tube – Seat Back
450-640
1Tachometer
11631-000 1Windshield
11635-000
1
Window – Front Sliding
11636-000
1
Window – Rear Sliding
Cockpit
PARTPER
NUMBER
SHIP
450-610
451-335
C-2300
11602-00
11602-07
11603-00
11633-00
11634-00
41481-07
41481-13
11484-00
11500-00
11628-00
11637-00
11650-02
11650-03
11651-000
11654-00
11655-00
11656-02
11656-03
11656-04
11653-00
NOMENCLATURE
1Altimeter
1
Belt Assembly – Safety
1Compass
1
Cushion – Seat Bottom (PA-15)
1
Cushion – Seat Bottom (PA-17)
1
Cushion – Seat Back
1
Collar – Windshield Front
1
Collar – Windshield Rear
1
Cable – Cabin Heat Control
1
Cable – Carb. Heat Control
1
Decal – Maneuverability (PA-17)
1
Decal – “No Smoking” (PA-17)
1
Decal – Maneuverability
1
Door Assembly
2
Strips – Door Window – Rear End
2
Strips – Door Window – Upper
1
Window – Door
1
Panel – Door Cover
1
Clip – Door Stop
1
Trimstrips – Door – Rear End
1
Trimstrips – Door – Upper
1
Trimstrips – Door – Front End
1
Frame Assembly – Door
Chassis and Brake
3
PARTPER
NUMBER
SHIP
NOMENCLATURE
U1140A-000
D2-113S
B27-59-1
B51-035
D15-25
D12-101
750-015
MS35266-61
A64-3
B21-35
Arm – Tailwheel Rudder
Brake Shoe Assembly
Block – Brake
Fairing – Inner
Flange – Brake Frame
Frame – Brake
Nut – Elastic Stop
Screw – Fillister Head
Spacer – Nozzle (Rubber Packing)
Spring – Retracting
1
2
12
2
2
2
2
2
2
12
CHASSIS AND BRAKE • MODELS PA-15 AND PA-17
750-031
451-705
750-980
750-981
750-982
750-983
750-984
AN316-4
750-986
750-987
AN501-10-4
750-989
750-990
750-991
750-992
750-993
11553-00
30721-00
U31702-002
U10566-003
U10567-000
B57-239
U71061-004
U15216-000
750-912
750-953
10143-81
10143-75
-11987-003
10034-04
U10034-002
U30491-000
U30541-002
U1478A-000
2
Tube Assembly – Rubber
2
Brake Cylinder
2Plunger
2
Packing Ring – Plunger Head
2Case
2
Ring – Look – Top Seal
2Clevis
2Nut
2
Spacer – Orifice – Plunger Brass
2
Screw – Breather – Filler
2
Screw – Side of Case
2
Washer – Side of Case
2
Seal – Top – Less Packing Rings
2
Packing Ring – Top Seal – Outer
2
Packing Ring – Top Seal – Inner
2Spring
2
*Brace Strut – Landing Gear (PA-15)
1
Clamp – Tail Springs
2
Cap – Hub – 800 x 4 Wheel
2
***Cover – Shock Cord (Less End Plate)
4
End Plate
2
Fitting – Brake Bleeder
2
Hose – Flexible Brake Cylinder
2
Hose – Flexible at Landing Gear Vee (PA-17) (Used
also PA-15 when landing gear brace struts replaced
with PA-17 shock struts)
1
Kit – Bolts and Nuts
1
Kit – Conversion Landing Gear to Brace Strut to Shock
Strut (PA-15)
2
Line – Non Flex. – Between Flex. Cylinder and
Landing Gear Lines (PA-17)
2
**** Line – Non Flex. – Between Flex. Cylinder and
Landing Gear Lines (PA-15)
2
Line – Non Flex. – to Landing Gear Vee (PA-15)
2
Line – Non Flex. – in Landing Gear Vee (PA-15)
2
Line – Non Flex. – in Landing Gear Vee (PA-17, also
PA-15 when landing gears replaced with #11551-00
and 01)
2
Nut – Landing Gear Axle
1
Pad – Tail Spring – Clamp
1
Spacer and Bushing Tailwheel Attachment
U2151A-000
U30512-002
U30512-004
11805-00
U11803-000
U11804-000
U11806-000
U31322-000
800X4X4
800X4
451-602
2077
750-636
750-369
760-367
750-354
1879
U1800A
491-070
491-075
11551-00
11551-01
U11554-000
U11554-001
U10034-002
U84322-000
U80022-063
UD3-13A-1
08125
08231
B227-52
UA56-4
UA85-218
A85-118
A20-54
415-773
B11-5
B13-4
AN441-6-6P
4
1
Spring Connector Assembly – Tailwheel (Pr.)
1
Spring Connector Assembly – Tailwheel – Short
1
Spring Connector Assembly – Tailwheel – Long
2
*** Strut Assembly – Shock (Complete)
2
Strut Assembly – Short Shock (Lower)
2
*** Strut Assembly – Long Shock (Upper)
4
*** Fitting Assembly – Shock Strut
4
*** Ring – Shock Cord
2
Tire – Cub (4 Ply)
2
Tube – Cub
1
Tailwheel Assembly – Scott No. 3000-A-1
1
Bracket (with Bushing)
1Fork
1
Hub Assembly (Less Tire)
1
Axle Assembly – (with Grease Fitting and Hub Caps)
2Bearing
1Tire
1
Bushing – Bracket
2
***** Union – Double Female at Upper End Landing
Gear Brake Line (PA-15)
2
** Union – Double Male (PA-15)
1
** Vee Assembly – Covered Landing Gear – LH
1
** Vee Assembly – Covered Landing Gear – RH
1
** Vee Assembly – Uncovered Landing Gear – LH
1
** Vee Assembly – Uncovered Landing Gear – RH
2
Line – Front Leg of Landing Gear Vee
2
** Nut – ¼ Flared Tube – Landing Gear Brake Line
4
Bushing – Landing Gear
2
Wheel and Brake Drum Assembly
4
Cone – Bearing
4
Cup – Bearing
4
Felt – Grease Retaining
8
Retainer – Felt
4
Lock Ring – Felt Retainer
2
Lock Ring – Side Ring Casting
2
Anchor Pin – Side Ring Casting
6
Screw (Hub Cap)
2
Casting – Side Ring
2
Brake Drum
12
Rivet – Brake Drum Attachment
CONTROL • MODELS PA-15 AND PA-17
* Conversion to shock struts – see kit part # 750-953 above
** On PA-15’s only, up to serial number 15-384, part numbers 491-075 and
84322‑00 required to install new type vee with ¼” flared tube nut upper end
gear brake line.
*** Used on PA-15 when converted from brace struts to PA-17 shock struts
**** Used only when original landing gear vee was replaced with vees number
11551-00 and -01 having ¼” flared tube nut upper end vee brake line
***** Used on PA-15’s up to serial number 15-384, with landing gear vees having
¼” male inverted nut upper end brake line. Not used with landing gear vee
part numbers 115510-00 and -01.
Control
PARTPER
NUMBER
SHIP
NOMENCLATURE
42592-00
42592-01
U42585-000
U42585-001
U42922-000
U42933-000
42585-02
42585-03
42585-04
42585-05
42585-06
42585-07
42585-08
42585-09
42585-10
42585-11
U42872-000
U41891-000
U40501-000
U42972-000
U42972-000
U40321-003
U41881-000
U40451-002
U40451-003
U40321-002
Aileron Assembly – Covered and Doped, LH
Aileron Assembly – Covered and Doped, RH
Aileron Assembly – Uncovered, LH
Aileron Assembly – Uncovered, RH
Edge – Aileron Inboard Trailing
Edge – Aileron Outboard Trailing
Leading Edge Section – LH – Inboard
Leading Edge Section – RH – Inboard
Leading Edge Section – LH – Center Inboard
Leading Edge Section – RH – Center Inboard
Leading Edge Section – LH – Center Outboard
Leading Edge Section – RH – Center Outboard
Leading Edge Section – LH – Tip
Leading Edge Section – RH – Tip
Aileron Rear Section – LH
Aileron Rear Section – RH
Rib – Aileron Tip
Hinge – Aileron Center
Horn – Aileron
Spar – Aileron LH
Spar – Aileron RH
Rib – Aileron (at Center Hinge)
Hinge – Aileron Inboard and Outboard
Bulkhead – Aileron (Flange Facing Left)
Bulkhead – Aileron (Flange Facing Right)
Rib – Aileron (all except Tip and at Center Hinge)
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
2
2
2
1
1
4
4
20
20
20
U40311-002
4
U40311-003
40461-00
2
2
U42491-000
4
U40421-003
U40581-002
U40581-003
U81362-005
U40411-000
11596-00
11850-00
11850-00
11897-00
11897-00
U80012-004
U80012-004
U80012-006
U80012-017
U80022-044
U80022-045
86102-48
-86102-027
86102-11
U86102-043
-10870-003
2
2
2
20
2
1
1
2
4
8
4
7
2
1
6
12
2
2
1
1
1
-10870-004
1
U11527-000
1
U40123-049
1
11638-00
2
U11641-002
1
U11641-003
1
U40123-050
1
U40123-057
U40123-058
1
U40123-058
2
U40123-059
1
5
Plate – Aileron Hinge Reinforcement (Inbound and
Outbound Upper)
Plate – Aileron Hinge Reinforcement (Center Upper)
Plate – Aileron Horn Hinge Lower Reinforcement
Center
Plate – Aileron Hinge Reinforcement Inbound and
Outbound
Tube – Aileron Tip
Braces – Aileron – LH
Braces – Aileron – RH
Reinforcement Plate – Aileron Rib – Top and Bottom
Reinforcement – Aileron Trailing Edge
Arm – Rudder Pedal Torque
Bracket – Pulley Elevator (PA-15)
Bracket – Pulley Elevator (PA-17)
Block – Bearing Control Torque Tube (PA-15)
Block – Bearing Control Torque Tube (PA-17)
Bushing – 1¾” Pulley (PA-15)
Bushing – 1¾” Pulley (PA-17)
Bushing – Stabilizer Tie Rod Attachment
Bushing – Elevator Cable Rear UpperLink Attachment
Bushing – Tail Surface – Long (Bronze)
Bushing – Tail Surface – Short (Bronze)
Bushing – Pulley Bracket
Bushing – Pulley Tab Cable
Bushing – Spacer – Rudder – Cable Pulley (PA-17)
Bushing – 1¾” Pulley – Rudder Cable – Left
Cable – Aileron LH – to Lower Aileron Horn on Struts
(PA-15)
***Cable – Aileron RH – to Lower Aileron Horn on
Struts (PA-15)
Cable – Aileron LH in Wing
Cable – Aileron RH in Wing
Cable – Tab Control
Cable – Rudder – to Left Horn
Cable – Rudder – to Right Horn
Cable – Bungee Control
Cable – Aileron (Torque Tube Connector) (PA-17)
*Cable – Front Elevator Control – Short (PA-15)
Cable – Front Elevator Control – Short (PA-17)
*Cable – Front Elevator Control – Long (PA-15)
CONTROL • MODELS PA-15 AND PA-17
U40123-059
U40123-060
U40123-060
U40123-051
U40123-052
11587-00
U61341-002
U61341-004
U61341-003
U61341-002
11626-000
U10911-000
U10911-000
11658-00
1166-00
U80002-060
2
2
4
1
1
2
2
2
2
2
1
3
5
1
2
1
-80222-023
U80222-024
41692-01
41692-02
-11579-000
U40572-000
U40701-000
U40701-000
U40071-000
U40081-000
40592-07
11577-00
11577-01
U10911-000
U10911-000
U10449-000
U41271-000
81352-13
81352-13
81262-39
U81262-046
U81262-046
11589-02
11589-02
2
2
1
1
1
1
6
8
12
11
1
1
1
3
5
1
1
2
4
2
6
7
1
2
Cable – Front Elevator Control – Long (PA-17)
*Cable – Elevator – Rear Both Sides (PA-15)
Cable – Elevator – Rear Both Sides (PA-17)
**Cable – Elevator Short Upper Horn (PA-15)
**Cable – Elevator Long Lower Horn (PA-15)
Clevis – Tab Control
Clevis – Stabilizer Tail Brace Wire Upper
Clevis – Stabilizer Tail Brace Wire Lower
Clevis – Fin Tail Brace Wire
Clevis – Fuselage Tie Rod
Control – Throttle
Knob – Throttle (PA-15)
Knob – Throttle (PA-17)
Channel – Hinge Tab Attachment
Clip – Tab Cable Attachment
Clamp – Round Bungee Cable to Stabilizer Attachment
Tube
Clamp – Rudder Pedal Torque Tube – Right (PA-17)
Clamp – Rudder Pedal
Elevator Assembly Covered RH
Elevator Assembly Covered LH
Elevator Assembly Uncovered LH
Elevator Assembly Uncovered RH
Fairlead Cable – Long (Less Snap Ring) (PA-15)
Fairlead Cable – Long (Less Snap Ring) (PA-17)
Fairlead Cable – Short (Less Snap Ring)
Ring – Fairlead Snap
Fin Assembly
Horn – Elevator Tab, Upper
Horn – Elevator Tab, Lower
Knob – Control Stick, Throttle, Tab Lever (PA-15)
Knob – Control Stick, Throttle, Tab Lever (PA-17)
Link – Elevator Horn Upper
Link – Elevator Horn Lower
Link – Front Elevator Cable (PA-15)
Link – Front Elevator Cable (PA-17)
Link – Rudder Pedal Return
Link – Rudder Pedal (PA-15)
Link – Rudder Pedal (PA-17)
Lever – Tab Control (PA-15)
Lever – Tab Control (PA-17)
U10211-000
U41051-000
10202-00
10913-00
10913-02
11726-00
11807-00
U41001-008
U41001-008
U43001-000
U80421-000
U80421-000
U60742-000
U60742-001
42163-02
U40622-000
U10940-000
U42891-000
11592-00
11845-00
11815-00
41652-00
41652-01
U40643-000
415-955
81102-15
81102-16
11594-00
11595-00
11808-00
11809-00
U11586-000
11585-05
11585-06
U86062-079
11578-00
11569-03
U40131-000
U81102-002
U80122-086
U41031-002
6
20
8
3
1
1
2
1
1
2
2
8
8
1
1
1
1
1
2
1
1
1
1
1
2
10
4
4
1
1
1
1
1
l
1
1
1
2
2
8
18
2
Nipple – Tab Cable Attachment
Nipple – Tail Brace Wires
Plate – Elevator Inspection Bottom, Left
Plug – Control Stick – Right (PA-17)
Plug – Control Stick – Knob
Pedal – Rudder and Brake
Pedal – Rudder (PA-17)
Pulley – at Torque Tube (PA-15)
Pulley – at Torque Tube (PA-17)
Pulley – Tab Cable
Pulley – (Elevator and Rudder Cable) (PA-15)
Pulley – (Elevator and Rudder Cable) (PA-17)
Panel – Tail Inspection LH
Panel – Tail Inspection RH
Rudder Assembly – Covered and Doped
Rudder Assembly – Uncovered
Spring – Bungee
Spring – Rudder Pedal Return
Stick – Control
Stick – Control – Right (PA-17)
Stub – Control Stick – Right (PA-17)
Stabilizer Assembly – Covered LH
Stabilizer Assembly – Covered RH
Stabilizer Assembly – Uncovered
Screw – Tab Control Lever Knob
Shim – Torque Tube Bearing
Shim – Torque Tube Bearing
Tube – Rudder Pedal Torque Left (PA-15)
Tube – Rudder Pedal Torque Right (PA-15)
Tube – Rudder Pedal Torque Left (PA-17)
Tube – Rudder Pedal Torque Right (PA-17)
Tube – Stabilizer Attachment Front
Tube – Torque Right (PA-17) Control Stick
Tube – Torque Left Control Stick
Tube – Rear Stabilizer Attachment
Tab Assembly – Elevator
Washer – Tab Control Lever
Washer – Fin Tie Rod Clevis
Washer – Square Tail Brace Wire Clevis
Washer – Tail Surface Hinge Pin
Wires – Tail Brace Upper Long
CONTROL • POWER PLANT • MODELS PA-15 AND PA-17
U41031-003
2
Wires – Tail Brace – Lower Short
U80032-034
U72691-000
-70591-003
U70591-002
AN742-3
71261-03
U12761-002
U19795-000
11609-00
11609-04
11624-00
11607-00
11606-00
11606-02
U91193-000
-73451-003
-10525-005
-74311-000
-82332-024
-82332-014
U71061-000
70322-30
U70322-012
11832-00
L11824-000
11534-00
11707-00
11713-00
73451-04
71451-05
-71451-003
U70912-000
11712-00
10764-02
U10843-000
U10764-000
11903-00
U11710-000
11827-00
*Used on PA-15’s serial numbers 15-383 and up only.
** Used on PA-15’s serial numbers up to 15-382 only.
***Two (2) each per ship used on PA-17.
Power Plant
PARTPER
NUMBER
SHIP
11929-00
11608-00
11277-00
-11278-000
-11279-000
-11279-002
11616-02
11616-03
11759-00
11765-00
-10922-000
U10923-000
-11282-000
-11283-000
11843-00
11840-00
11841-00
11839-00
11837-00
11838-00
11838-04
-11491-000
454-882
-80032-004
80032-19
11622-00
11813-00
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
11814-00
1
NOMENCLATURE
Baffle – Carburetor Air Box
Box – Carburetor Air
Bracket – Baffle Right Front (PA-17)
Bracket – Baffle Left Front (PA-17)
Bracket – Baffle Left Rear (PA-17)
Bracket – Baffle Right Rear (PA-17)
Baffle Assembly – Left (PA-15)
Baffle Assembly – Right Side (PA-15)
Baffle – Left Top (PA-15)
Baffle – Right Top (PA-15)
Baffle – Intercylinder – Inner (PA-17)
Baffle – Intercylinder – Outer (PA-17)
Baffle – Left Front (PA-17)
Baffle – Right Front (PA-17)
Baffle – Rear Right (PA-17)
Baffle – Rear Left (PA-17)
Baffle – Rear Center (PA-17)
Baffle – Right Side Front (PA-17)
Baffle – Left Side Front (PA-17)
Baffle – Side Rear Left (PA-17)
Baffle – Side Rear Right (PA-17)
Baffle – Engine Oil Well (PA-17)
Clamp – Breather Tube Connection Upper
Clamp – Engine Breather Lower (PA-15)
Clamp – Engine Breather Lower (PA-17)
Clamp – Throttle Control at Engine Mount (PA-15)
Clamp – Throttle Control Attachment to Engine Mount
(PA-17)
Clamp – Throttle Control Attachment to 11813-00
(PA‑17)
7
1
1
4
1
2
1
1
14½”
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
Clamp – Offset Carburetor Heat Control
Clamp – Tailpipe to Muffler
Clamp – Exhaust Stack at Port (PA-15)
Clamp – Exhaust Stack to Muffler
Clamp – Cabin Heat Control to Firewall
Clip – Muffler – Shroud Slide
Cover – Inspection Top Cowl (Less Beading)
Beading – Rubber
Cover – Carburetor Air Box (PA-15)
Cover – Carburetor Air Box (PA-17)
Cowl – Engine Nose
Cowl – Engine Bottom
Cowl – Engine Top (PA-15)
Cowl – Engine Top (PA-17)
Fitting – Swivel Throttle Shaft to Carb
Gasket – Carb Airscoop Attachment (Vellumoid)
Hose – Air (Muffler to Cabin Heat Box)
Hose – Breather Tube Connection
Line – Oil Pressure Copper (PA-17)
Line – Oil Pressure Copper (PA-15)
Line – Oil Pressure Flexible
Line – Flexible Fuel Strainer to Carburetor (PA-15)
Line – Flexible Fuel Strainer to Carburetor (PA-17)
Link Mixture Control at Engine Mount (PA-17)
Mount – Engine (PA-17)
Mount – Engine (PA-15)
Plate – Cabin Air Deflector
Plate – Exhaust Stack Shroud End (PA-15)
Plate – Carburetor Airscoop Attachment (Steel)
Propeller – Sensenich 70LY36 (PA-15)
Propeller – Sensenich 72CK42 (PA-17)
Rod – Engine Baffle Tie Inner (PA-17)
Rod – Engine Baffle Tie Outer (PA-17)
Shroud – Tailpipe
Shroud – Left Exhaust Stack Lower (PA-15)
Shroud – Left Exhaust Stack Upper (PA-15)
Shroud – Left Exhaust Stack Lower (PA-17)
Shroud – Left Exhaust Stack Upper (PA-17)
Shroud – Muffler (PA-17)
Shroud – Muffler (PA-15)
Spacer – Air Box to Carburetor (PA-17)
POWER PLANT • FUEL SYSTEM • MODELS PA-15 AND PA-17
U70671-000
11831-00
73163-02
11709-00
10836-00
U70371-003
U10920-000
70701-00
U74501-000
11708-00
AD2
U85012-047
-81342-019
-80122-043
U81342-022
1
1
1
1
4
1
4
1
1
1
4
22
1
4
4
Stack Assembly – Right Exhaust (PA-17)
Stack and Muffler Assembly – Exhaust Left (PA-17)
Stack – Exhaust RH (PA-15)
Stack and Muffler Assembly – Exhaust Left (PA-15)
Screw – Carburetor Air Box Attachment (PA-15)
Stud – Carburetor Heat Control Attachment
Support – Intercylinder Baffle Hangar (PA-17)
Tailpipe – Exhaust (PA-15)
Tailpipe – Exhaust (PA-17)
Tube – Engine Breather
Tubing – 21⁄8” OD Flexible
Washer – at Cowling Screws
Washer – Carburetor and Mixture Control Attachment
Washer – Mount to Firewall Fibre
Washer – Mount to Engine Fibre (PA-17)
U70322-012
3326X4
105X2
105X2
U451-100
72302-00
U12764-000
U12764-000
U87477-002
U85012-032
U72302-003
U750-272
U750-273
U750-268
10016-15
U80111-000
11612-00
U72091-000
11590-00
70151-00
70281-02
11662-00
702X2
74032-00
U80122-048
Fuel System
PARTPER
NUMBER
SHIP
U71991-000
11953-00
11664-00
80032-02
450X6
402X6
352X6
3400X4
U91193-000
1
1
1
1
1
1
1
1
1
U91193-000
2
11662-00
U31197-000
-10143-009
-10143-063
10143-77
10143-79
-71242-006
-71242-007
70322-30
1
2
1
1
1
2
1
1
1
NOMENCLATURE
Bracket – Fuel Strainer
Cap – Fuel Tank (See Note)
Cap – Fuel Tank (See Note)
Clamp – Offset Fuel Tank Throttle Attachment
Elbow – at Fuel Strainer Intake
Elbow – Fuel at Carburetor (PA-15)
Elbow – Fuel at Carburetor (PA-17)
Elbow – Gas Shut Off to Tank (PA-17)
Fitting – Swivel Throttle Attachment to Carburetor
(PA‑15)
Fitting – Swivel Throttle Attachment to Carburetor
(PA‑17)
Gauge Assembly – Fuel Tank
Jet – Primer (Straight) (PA-15)
Line – Primer Pump Outlet (PA-15)
Line – Primer Pump Intake (PA-15)
Line – Fuel Valve to Fuel Strainer
Line – Primer – Tee to Primer Jets (PA-15)
Line – Primer Inlet Short Copper (PA-17)
Line – Primer Outlet Long Copper (PA-17)
Line – Flexible Fuel Strainer to Carburetor (PA-15)
1
Line – Flexible Fuel Strainer to Carburetor (PA-17)
2
Nipple (at Fuel Strainer Inlet)
1
Nut – 1⁄8 Inverted – For Primer Line (PA-17)
5
Nut – 1⁄8 Inverted – For Primer Line (PA-15)
1
Primer Pump
1
Strainer Assembly – Fuel
1
Bowl – Standard
1
Bowl – EZ – Drain Type
1Cover
1Gasket
1Nut
1Screen
1Seat
1
Wire Assembly – Bail
6
Strip – Felt Cemented to Tank Strap and Support Tube
2
Stud – Gas Tank Strap
4
Straps – Fuel Tank
1
Strainer – Gas Tank Finger
1
Tank Assembly – Fuel
1
Plug – Fuel Tank Drain
1
Collar – Fuel Tank Gauge – Male
1
Gauge Assembly – Fuel
1
Tee – Triple Inverted (Primer) (PA-15)
1
Valve – Fuel
1
Washer – Fuel Tank Neck – Rubber
NOTE: Part number 11953‑00 used on PA‑15 ships serial #15‑1 to 15‑263, 15‑265
to 15‑320, 15‑322 to 15‑326, 15‑330, 115‑332, 15‑358, 15‑364 and 15366, and
PA‑17 ships serial 17‑1 to 17‑47, 17‑49,17‑56,17‑57 and 17‑59 to 17‑61, 17‑67,
17‑68, 17‑75, 17‑110 to 17‑112. All ships not listed above use part number
11664‑00.
8
ACCESSORIES AND MISCELLANEOUS
Accessories and Miscellaneous
PART
NUMBER
NOMENCLATURE
MODEL
750-945
750-946
750-947
750-954
Fenders Comp. Model 16
Fenders Comp. Model 16
Fenders Comp. Model 17
Fenders Body Set Model 17– Less Brackets
750-957
750-960
750-961
750-958
750-962
750-963
750-959
750-964
750-965
750-709
12061-00
12061-02
750-858
750-859
750-860
750-861
750 941 Fender Bracket Sets
Fender Bracket – Inside Left
*Fender Bracket – Inside Right
Fender Bracket Sets
Fender Bracket – Inside Left
*Fender Bracket – Inside Right
Fender Bracket Sets
Fender Bracket – Inside – Left
*Fender Bracket – Inside – Right
Propeller Spinner Assembly
Floor Mat
Floor Mat
Sun Visor (12 x 6”Adjustable Clamp)
Tie Down Rings – Mooring (Sets)
Tie Down Rings – Mooring (Sets)
Tie Down Rings – Mooring (Sets)
Tie Down Rings-Mooring (Sets) 750-942
Tie Down Rings-Mooring (Sets)
750-943
750-944
Tie Down Rings-Mooring (Sets)
Tie Down Rings-Mooring (Sets)
Cessna 120‑140
Stinson 4 Place
Aeronca 7A‑11A
J3, PA‑11, 12, 14,
15, and 17
J3, PA‑11
J3, PA‑11
J3, PA‑11
PA‑12, 14
PA‑12, 14
PA‑12, 14
PA‑15, 17
PA‑15, 17
PA‑15, 17
J3, PA‑11, 15, 17
PA‑15
PA‑17
All Models
J3
PA‑11, 15, 17
PA‑12, 14
Taylorcraft – All
Models
Aeronca L38,
Piper J4-J5
Cessna 120-140
Stinson 150-165
750-871
750-872
750-881
750-882
750-883
750-884
750-877
750-878
750-879
750-880
750-885
750-886
750-887
750-889
*Includes 6 each: Maroon, Yellow, Blue, and Cream
Miscellaneous Items
PART
NUMBER
U19795-000
415-31130-10
187-600
U750-287
00031-24
750-286
U750-285
X141472
U750-285
NOMENCLATURE
Beading – Strut Cuff (Cowling)
Beading – Wing Root Covers
Beading – Windshield
Brace – Rib – 6 ft. Section
Capstrip Rib Repair – 12” Pieces
Capstrip Rib Repair – 6’ Section
Channel – “U’’ – Steel (3⁄8”) 6’ Section
Channel – “U’’ – Steel (¼”) 6’ Section
Channel – “U’’ – Aluminum (3⁄8”) 6’
Section
750-856
E-Z Drain Gascolator – Bowl (Size 2”
O.D. Bowl – Tillotson Gascolator)
U12764-000
E-Z Drain Gascolator Bowl (Size 21⁄8”
O.D. Bowl – Kem Gascolator)
460-025
Fastener – Cowl Fastener Dzus
MS35489-11 Grommet – Rubber 3⁄8”
AN931-10-14 Grommet – Rubber 5⁄8”
MS35489-22 Grommet – Rubber 7⁄8”
463-370
Grommet – Cowl Fastener Dzus
*750-966 Axle Tube – Fenders and Pants (2 required)
Aircraft Polish – Kote-O-Wax
750-867
750-868
750-873
750-869
750-870
Kote-O-Wax Blue (Case of 24 pints)
Kote-O-Wax Cream (Case of 24 pints)
Kote-O-Wax Maroon (Pint can)
Kote-O-Wax Yellow (Pint can)
Kote-O-Wax Blue (Pint can)
Kote-O-Wax Cream (Pint can)
Kote-O-Wax Maroon (Case of six 1-gallon cans)
Kote-O-Wax Yellow (Case of six 1-gallon cans)
Kote-O-Wax Blue (Case of six 1-gallon cans)
Kote-O-Wax Cream (Case of six 1-gallon cans)
Kote-O-Wax Maroon (gallon can)
Kote-O-Wax Yellow (gallon can)
Kote-O-Wax Blue (gallon can)
Kote-O-Wax Cream (gallon can)
Kote-O-Wax Floor Display Rack
Kote-O-Wax Counter Display Rack
*Kote-O-Wax Mixed (Case of 24 pints)
Kote-O-Wax Maroon (Case of 24 pints)
Kote-O-Wax Yellow (Case of 24 pints)
9
FIG.
MODEL
A
PA-11, 12, 14, 15,
17
B
PA-12, 14, 15, 17
C
J3, J4, J5, PA-11
All Models
All Models
All Models
All Models
All Models
All Models
J3, J4, J5
All Models
PA-12, 14
All Models
All Models
All Models
PA-12, 14
ACCESSORIES AND MISCELLANEOUS
-187-030
750-849
187-500
Hose – Rubber 3⁄16” I.D. (Airspeed)
Kit Per Service Letter #110 (Ram Type
Carburetor Air Box Replacement)
Kit – (Aircraft Tie Down)
Kit – 5⁄16” (Landing Gear Bolts and
Nuts)
Kit – (Special Assembly #54)
(Fuselage Aileron Pulley Installation)
Kit – (Special Assembly #55)
(Tailwheel)
Kit – (Rib Repair)
Kit – (Rib Repair)
Kit – (3⁄8” Landing Gear Bolts and
Nuts)
Kit – (Plexiglas Windshield
Installation)
Kit – (Landing Gear Bolts and Nuts)
Kit – Front Spar Splice Metal
Kit – Rear Spar Splice Metal
Kit – Front Spar Splice Metal
Kit – Rear Spar Splice Metal
Kit – For Converting to Four Cylinder
Priming
Landing Lamp – Grimes Selfretractable (Model ST-250-12 Volt 6”
Reflector)
Landing Lamp – Grimes #G3201 (24
Volt – AN3095-2 8” Reflector)
Moulding – Windshield
D
187-510
187-607
-187-610
187-540
Moulding – Door
Moulding – Door
Moulding – Door
Moulding – Door
E
F
G
H
750-247
750-250
750-253
750-254
750-454
750-456
-750-611
750-634
750-912
-750-736
-750-737
-750-738
-750-739
750-763
496-176
750-660
All Models
PA-12
426-420
426-422
All Aircraft
J3
Nail Spar – Cement Coated – 18 Gauge
x ½”
Nail Spar – Cement Coated – 18 Gauge
x ¾”
NOTE: All navigation lights listed below are Grimes Model “A” Tail, “B”
Wing Type, applicable all Piper Cubs.
J3, 1937 to 1942
J3, 1937 to 1942
496-175
496-178
750-232
496-180
750-233
496-181
750-234
750-890
472-657
750-232
472-656
750-233
472-655
750-234
J3, PA-11, 15, 17
J4-41, PA-12, 14
J3, PA-11
J3, 1937 to 1942
PA-15, 17
PA-11, J3
PA-11, J3
PA-12, 14
PA-12, 14
PA-12
Navigation Light (Set of 3) (6 Volt)
Tail Light – Clear
Lens – Tail – Clear
Wing Light – Left – Red
Lens – Wing – Red
Wing Light – Right – Green
Lens – Wing – Green
Navigation Light (Set of 3) (12 Volt)
Tail Light – Clear
Lens – Tail – Clear
Wing Light – Left – Red
Lens – Wing – Red
Wing Light – Right – Green
Lens – Wing – Green
NOTE: Following Piper Cub Log Books
-750-111
750-112
750-113
750-114
180-510
186-030
186-018
185-130
J3 (1937 to 1942),
J4
PA-12
PA-11
PA-11
PA-14
10
Aircraft – Standard
Engine – Standard
Pilot – Black Imitation Leather
Pilot – Green – Homespun Cover
Padding – Fuel Tank Strap Felt ¼” x ⅞”
Plexiglas – Sheet .100 x 29” x 42⅜” Clear
Plexiglas – Sheet .080 x 40” x 50” Clear
Pyralin – .030 x 21” x 50”
All Models
ACCESSORIES AND MISCELLANEOUS
Special Cub Tools
185-150
Pyralin – .050 x 21” x 50”
486-563
Shackle – Cable 3⁄32 or ⅛” Cable
All Models
488-564 Thimble – (AN100-3) l⁄16” Cable (Per C Only)
488-565
Thimble – (AN100-4) ⅛” Cable (Per C Only)
All Models
489-609
Turnbuckle Assembly – 3⁄32 or ⅛” Cable
All Models
101-680
Tubing – Aluminum Flexible 1” (per foot) J3, J5, PA‑11, 12, 14
AD2
Tubing – Aluminum Flexible 2⅛” (per foot)
All Models
100-124
Tubing Round Aluminum Airspeed – .032 x 3⁄16”
All Models
103-084
Tubing Round Copper – .032 x ⅛”
103-124
Tubing Round Copper – .032 x ¼”
103-563
Tubing Round Copper – .032 x ⅝”
WEBBING-1/2Webbing – Cowl (per foot) – ⅛” x ⅝”
All Models
*11904-00
**10508-00
**83851-00
11852-00
Shock Cord Tool Assembly
Shock Cord Tool Assembly
Installation Tool – Shock Cord
Tool – Gas Gauge
PA-14
PA-12, 14
J3
PA-15, 17
* Installation and removal (S.M. #15)
** Installation only
McCauley Met-L-Props
NOTICE: Refer to McCauley Met-L-Prop List, immediately following, to obtain proper model designation, which will allow conversion from McCauley model number to
Piper part number for ordering.
PART
NUMBER
NOMENCLATURE
750-783.....................................CF7038 Tapered Shaft
750-784.....................................CF7038 Flanged Shaft
750-918.....................................CF7040 Tapered Shaft
750-919.....................................CF7040 Flanged Shaft
750-920.....................................CF7142 Tapered Shaft
750-921.....................................CF7142 Flanged Shaft
750-779.....................................CF7144 Tapered Shaft
750-780.....................................CF7144 Flanged Shaft
750-812.....................................CF7146 Tapered Shaft
750-843.....................................CF7146 Flanged Shaft
750-775.....................................CF7148 Tapered Shaft
750-776.....................................CF7148 Flanged Shaft
750-922.....................................CF7150 Tapered Shaft
750-923.....................................CF7150 Flanged Shaft
750-837.....................................CF7151 Tapered Shaft
750-838.....................................CF7151 Flanged Shaft
750-933............................................................ CF7152
750-924.....................................CF7154 Tapered Shaft
750-925.....................................CF7154 Flanged Shaft
750-777.....................................CF7351 Tapered Shaft
750-778.....................................CF7351 Flanged Shaft
750-773.....................................CF7443 Tapered Shaft
750-774.....................................CF7443 Flanged Shaft
750-785.....................................CF7443 Tapered Shaft
750-786.....................................CF7443 Flanged Shaft
750-785.....................................CF7445 Tapered Shaft
750-786.....................................CF7445 Flanged Shaft
750-781.....................................CF7447 Tapered Shaft
750-782.....................................CF7447 Flanged Shaft
750-926.....................................CF7449 Tapered Shaft
750-927.....................................CF7449 Flanged Shaft
750-844...........................................................CM7149
750-917...........................................................CM7152
750-924....................................CM7154 Tapered Shaft
750-925................................... CM7154 Flanged Shaft
750-929............................................................ DM647
750-928.......................................................... DM7653
750-930.......................................................... DM7649
750-931.......................................................... DM7652
750-932.......................................................... DM7654
McCauley Met-L-Prop Extra Installation Kits
750-840
CF Kit (for flanged shaft installation
using 90 hp or under)
750-802
CH Kit (for tapered shaft installation
using 90 hp or under)
11
750-897
1A170 Kit (for #3 flanged crankshaft
installation using DF & DM propeller)
ACCESSORIES AND MISCELLANEOUS
McCauley Corporation Met-L-Prop List
AIRPLANE MODEL
Aeronca
65-C, 65-CA Land Plane
S65-C, S65-CA Sea Plane
058-B Land Plane
S058-B Sea Plane
7AC Land Plane
S7AC Sea Plane
7BCM
7DC
11AC Land Plane
S11AC Sea Plane
11CC
15AC
Cessna
120, 140 Land Plane
120, 140 Sea Plane
140 (1948 Model)
170
Commonwealth
“Skyranger” 185
Ercoupe
415-C, 415-D
415-E
Funk
B85-C
Interstate
S-1A-65F
Luscombe
8A Land Plane
8AS Sea Plane
8C Land Plane
8CS Sea Plane
STANDARD
CRUISING
CF7443
CF7443
CF7443
CF7443
CF7445
CF7443
CF7144
CF7144
CF7445
CF7443
CF7144
DM7647
CF7445
CF7445
CF7445
CF7445
CF7447
CF7445
CF7146
CF7146
CF7148
CF7142
CF7154
DM7653
(Replaces DF7653)
CF7150
CF7144
TAKE OFF, CLIMB,
HIGH ALT.
A65-8
CF7445
CF7443
A65-8
CF7443
C85-8J
C85-8
A65-8
C85-8
C145-2
CF7146
C85-12
CF7152
C90-12
C145-2
CF7146
C85-12
CF7351
CF7150
CF7148
CF7150
CF7445
CF7447
CF7447
CF7144
CF7144
CONTINENTAL ENGINE
(UNLESS OTHERWISE SPECIFIED)
A65-3, 3J, -7, -7J, -8, -8J, -9, -9J
CF7148
C75-12
C85-12
CF7146
C85-12
A65-8
CF7449
CF7449
CF7146
CF7146
A65-3, -3J, -6, -6J, -7, -7J, -8, -8J, -9, -9J
A75-6, -8, -8J, -9, -9J
12
ACCESSORIES AND MISCELLANEOUS
AIRPLANE MODEL
8D Land Plane
8E Land Plane
8ES Sea Plane
8F
Piper
J3C-65 Land Plane
J3C-65 Sea Plane
J4A Land Plane
J4A-S Sea Plane
J4E Land Plane
PA-11
J5A
Stinson
HW-10, HW-75
108, -1 Land Plane
108, -1 Sea Plane
108-2, -3 Land Plane
108-2, -3 Sea Plane
Taylorcraft
BC12-65
BC12-D Land Plane
BCS-12D Sea Plane
DCO-65
NOTES:
STANDARD
CRUISING
CF7144
CF7151
CF7144
CM7154
CF7146
CF7443
CF7443 (a)
CF7443
CF7443
CF7038
CF7445
CF7144
CM7149
CF7038
CF7449
CF7146
CF7445
CF7445 (b)
CF7445
CF7445
TAKE OFF, CLIMB,
HIGH ALT.
CF7148
CF7142
CM7152
CF7038
CF7040
CF7146
DM7652
DM7649
DM7654
DM7649
CF7445
CF7445
CF7443
CF7443
CONTINENTAL ENGINE
(UNLESS OTHERWISE SPECIFIED)
A75-8, -8J, -9, -9J
C85-12
C90-12
A65-3, -6, -7, -8, -9, -14
A65-3, -6, -7, -8, -9
A75-8, -9
A65-3, -6, -8, -9, -14
C85-8J
C90-12
A75-8, -9
C75-12
C85-12
CF7447
CF7146
CF7038
CF7144
A75-3, -6, -8, -9
A80-6, -6J, -8, -8J, -9, -9J
C85-12, -12F
Franklin 6A4-150-B3
DM7652
Franklin 6A4-165-B3
DM7654
DM7652
DM7652
CF7447
CF7447
CF7445
CF7445
A65-7, -7J, -8, -8J
A65-7, -7J, -8, -8J
A65-8
(a) Eligible for Edo, McKinley, Wollam and Heath floats.
(b) Eligible for Edo and McKinley floats only.
13