INSTALLATION GUIDE
RESIDENTIAL MASONRY
2016
C1-C4_MacGuideTecInst16.indd 2
2016-02-19 9:19 AM
2
MacGuideTecInst16_Eng.indd 2
2016-01-29 9:55 AM
INDEX
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
MONDRIAN STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
LAFITT STONE/LAFITT ALTO . . . . . . . . . . . . . . . . . . . . . . . . 8
LEXA STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
DUFFERIN PLUS STONE . . . . . . . . . . . . . . . . . . . . . . . . . . 12
LAMINA STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
CINCO STONE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
CINCO BRICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
MELVILLE NORMAN BRICK NEW . . . . . . . . . . . . . . . . . . . . . 19
MELVILLE SLIK BRICK . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
URBANIKA BRICK AND STONE . . . . . . . . . . . . . . . . . . . . . . 21
CARDIFF ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
SEAMLESS TEXTURES AND
HATCHING PATTERNS LIBRARY . . . . . . . . . . . . . . . . . . . . . 24
INDEX – 3
MacGuideTecInst16_Eng.indd 3
2016-01-29 9:55 AM
INTRODUCTION
THE PURPOSE OF THIS GUIDE IS TO EXPLORE IN MORE
SUGGESTION NO 2
AVOID LONG VERTICAL OR HORIZONTAL JOINTS
DETAIL CERTAIN AESTHETIC CHARACTERISTICS OF
PERMACON’S PRODUCTS AND PRESENT SEVERAL BEST
To maintain an aesthetic appearance of the wall, we suggest taking the
PRACTICES WITH REGARDS TO MASONRY INSTALLATION.
height of the largest stone as the maximum reference for the vertical
WE HOPE THIS GUIDE WILL HELP YOU ACHIEVE IN THE
joints. Concerning the length of the horizontal joints, they should be less
BEST POSSIBLE WAY YOUR MASONRY PROJECTS USING OUR
than 4 feet long.
EXTENSIVE PRODUCT LINES.
WE HAVE INCLUDED SOME SUGGESTIONS TO FOLLOW WHEN
INSTALLING MASONRY.
4 feet max
PLEASE NOTE ALL PERMACON PRODUCTS ARE
Max
MANUFACTURED WITH NATURAL INGREDIENTS LIKE SAND
AND STONE. THEREFORE, IT IS NORMAL AND DESIRABLE THAT
See “Tricks” page 4
THE FINAL BUILDING APPEARANCE SHOWS COLOR VARIATION.
SUGGESTION NO 3
PROVIDE A MINIMUM OVERLAP OF 4 INCHES
The minimum overlapping of the stone should be a minimum of 4 inches.
SUGGESTION NO 1
AVOID BOXES
When a group of stones forms a compartment (rectangle or square) it
creates joints that should be broken. Adding a different dimension stone
usually solves the problem. However, in some projects, such as small
4 inch
columns or pilasters, it is difficult (or impossible) to avoid them.
AVOID
GOOD PRACTICE
These are just a few basic rules to help you successfully complete
your masonry project.
For further technical information we suggest you to consult
the following sources:
• In English: CSA Standards, Applicable Building Code and the CCMPA.
• In French: IMQ, Normes CSA and Code National du Bâtiment
4 – INTRODUCTION
MacGuideTecInst16_Eng.indd 4
2016-01-29 9:56 AM
TRICKS (Regarding suggestion NO 2)
To avoid long joints, we recommend that you follow these two
simple tricks:
Trick NO 1
Trick NO 2
Install a small (S) and a medium (M) size stone beside a large (L) stone.
For two courses, alternate a sequence of small (S) and medium (M)
stones. This technique is particularly efficient to avoid long horizontal
joints.
S
M
S
L
M
S
M
GENERIC CROSS SECTION FOR A MASONRY INSTALLATION
TYPICAL WOOD STUD WALL
CONSTRUCTION:
TYPICAL CONCRETE BLOCK
WALL CONSTRUCTION:
1/2 in gypsum board
1/2 in gypsum board
1 in wood furring
1 in metal furring
Vapor barrier
Concrete block
2 in x 6 in wood studs
Insulation
with 6 in batt insulation
1 in air gap
Exterior sheeting
3 1/2 Masonry Veneer
Air-barrier
1 in air gap
3 1/2 Masonry Veneer
Typical masonry wall ties
Typical masonry wall ties
Flashing
Flashing
10 in foundation wall
10 in foundation wall
BEST PRACTICES – 5
MacGuideTecInst16_Eng.indd 5
2016-01-29 9:56 AM
MONDRIAN® STONE
DESCRIPTION
CHOICE OF PROPORTIONS | Large Stones of 7 13/16 in (198 mm)
This new innovative generation of stone will add prestige and distinction
to your design. Its texture, defined edges, slightly chiselled surfaces and
slender forms provide a modern look. Available in three exclusive trendy
colours — it can be installed in linear or modular patterns and blends
perfectly with our Mondrian landscaping products.
Characteristics and benefits
• Proposes a cutting-edge style with an attractive texture.
• Is available in three trendy and contemporary colours.
1 CUBE OF LARGE STONES +
2 CUBES OF SMALL AND MEDIUM
STONES – LINEAR PATTERN
• Allows for a modular or linear installation.
• Reduces the number of cuts required and
1 CUBE OF LARGE STONES +
2 CUBES OF SMALL AND MEDIUM
STONES – MODULAR PATTERN
waste due to its modular dimensions.
• Includes a percentage of stones with textured ends to achieve corners.
• Matches perfectly with our landscaping products, including Trafalgar
paver, Mondrian paver and slabs.
1 CUBE OF SMALL AND MEDIUM STONES
LINEAR PATTERN
MODULES
A
C
3 1/2 in x 3 in x variable
3 1/2 in x 7 13/16 in x variable
90 mm x 76 mm x variable
90 mm x 198 mm x variable
(Sold separately)
B
3 1/2 in x 4 1/2 in x variable
90 mm x 114 mm x variable
6 – DESCRIPTIVE DATA SHEET / MONDRIAN® STONE
MacGuideTecInst16_Eng.indd 6
2016-01-29 9:56 AM
SIZES – STONE CLADDING
90 mm
3 1/2 in*
457 mm
18 in*
508 mm
20 in*
559 mm
22 in*
609 mm
24 in*
660 mm
26 in*
711 mm
28 in*
76 mm
3 in*
114 mm
4 1/2 in*
198 mm
7 13/16 in*
* The dimensions are actual. Allow a 1/3 in (8 mm) mortar joint in order to obtain nominal dimensions.
DESCRIPTIVE DATA SHEET / MONDRIAN® STONE – 7
MacGuideTecInst16_Eng.indd 7
2016-01-29 9:57 AM
LAFITT® STONE / LAFITT® ALTO STONE
DESCRIPTION
CHOICE OF PROPORTIONS | Large stones of 11 1/2 in (292 mm)
Lafitt stone will amaze you with the natural look of its subtle colour
tones and a texture that evokes — incredibly — stone carved by a
stonemason. Replacing proportions of stones with the Lafitt Alto Stone
with its enhanced texture will contribute to overall richness and aesthetic
success. Lafitt stone is also a technical achievement that contributes
tangibly to sustainable development through minimal loss and waste
during installation.
10 %
Characteristics and benefits
•
Unique pigmentation process, resulting in a product that maintains its
colour year after year.
•
Hand chiselled texture reminiscent of stone.
•
Total design freedom:
-
Choice of large stone ratios
-
Choice of stone ratios with enhanced texture (Lafitt Alto)
-
Choice of colour ranges (elemental and duos)
•
Modular formats = less cutting and waste = material savings.
•
Perfect complement to our bricks and several Permacon
landscaping products.
9 cubes of 4 in (102 mm)
and 7 in (178 mm)
for 1 cube of 11 1/2 in (292 mm)
25 %
3 cubes of 4 in (102 mm)
and 7 in (178 mm)
for 1 cube of 11 1/2 in (292 mm)
50 %
1 cube of 4 in (102 mm)
and 7 in (178 mm)
for 1 cube of 11 1/2 in (292 mm)
UNITS (ALL SIZES ARE AVAILABLE IN LAFITT OR LAFITT ALTO)
A
C
3 1/2 in x 4 in x variable
3 1/2 in x 11 1/2 in x variable
90 mm x 102 mm x variable
90 mm x 292 mm x variable
(Sold separately)
B
3 1/2 in x 7 in x variable
90 mm x 178 mm x variable
8 – DESCRIPTIVE DATA SHEET / LAFITT® STONE / LAFITT® ALTO STONE
MacGuideTecInst16_Eng.indd 8
2016-01-29 9:58 AM
SIZES – VENEER STONE
7 in*
(178 mm)
8 1/2 in*
(216 mm)
10 in*
(254 mm)
11 1/2 in*
(292 mm)
13 in*
(330 mm)
14 1/2 in*
(368 mm)
16 in*
(406 mm)
11 1/2 in*
(292 mm)
7 in*
(178 mm)
4 in*
(102 mm)
Depth
3 1/2 in*
(90 mm)
13 in*
(330 mm)
14 1/2 in*
(368 mm)
16 in*
(406 mm)
17 1/2 in*
(444 mm)
19 in*
(483 mm)
20 1/2 in*
(521 mm)
Note: *The dimensions are actual. Allow a 1/2 in (13 mm) mortar joint in order to obtain
nominal dimensions.
Note: *The dimensions are actual.
DESCRIPTIVE DATA SHEET / LAFITT® STONE / LAFITT® ALTO STONE – 9
MacGuideTecInst16_Eng.indd 9
2016-01-29 9:58 AM
LEXA® STONE
DESCRIPTION
CHOICE OF PROPORTIONS | Large Stones of 7 13/16 in (198 mm)
The Lexa stone is an innovative product with clean lines to achieve a
modern masonry veneer look. Thanks to its avant-garde style, this new
veneer is infused with elegance and simplicity.
Characteristics and benefits
• Proposes a cutting-edge style with an attractive texture.
• Offers a streamlined appearance.
• Is available in four exclusive colours.
• Allows for a modular or linear installation.
1 CUBE OF LARGE STONES +
2 CUBES OF SMALL AND MEDIUM
STONES – LINEAR PATTERN
• Reduces the number of cuts required and
waste due to its modular dimensions.
1 CUBE OF LARGE STONES +
2 CUBES OF SMALL AND MEDIUM
STONES – MODULAR PATTERN
• Presents chamfered edges to accentuate
clean lines.
• Includes a percentage of stones with finished ends to achieve corners.
• Matches perfectly with our landscaping products, including Lexa paver
and slab, Mondrian paver and slabs and Esplanade slab.
1 CUBE OF SMALL AND MEDIUM STONES
LINEAR PATTERN
MODULES
A
C
3 1/2 in x 3 in x variable
3 1/2 in x 7 13/16 in x variable
90 mm x 76 mm x variable
90 mm x 198 mm x variable
(Sold separately)
B
3 1/2 in x 4 1/2 in x variable
90 mm x 114 mm x variable
10 – DESCRIPTIVE DATA SHEET / LEXA® STONE
MacGuideTecInst16_Eng.indd 10
2016-01-29 9:59 AM
SIZES – STONE CLADDING
90 mm
3 1/2 in*
457 mm
18 in*
508 mm
20 in*
559 mm
22 in*
609 mm
24 in*
660 mm
26 in*
711 mm
28 in*
76 mm
3 in*
114 mm
4 1/2 in*
198 mm
7 13/16 in*
* The dimensions are actual. Allow a 1/3 in (8 mm) mortar joint in order to obtain nominal dimensions.
DESCRIPTIVE DATA SHEET / LEXA® STONE – 11
MacGuideTecInst16_Eng.indd 11
2016-01-29 9:59 AM
DUFFERIN® PLUS STONE
DESCRIPTION
CHOICE OF PROPORTIONS | Large stones of 9 1/2 in (240 mm)
This modular stone offers a rustic and classic approach.The Dufferin Plus
stone has wavy texture with soft edges.
Characteristics and benefits of Dufferin Plus stone
•
Affordably priced.
•
Material savings – modular dimensions and accessories reduce the
number of cuts required as well as waste.
•
Design flexibility – choice of two types of joints that provide very
different looks, variable proportions of large stones and accessories to
create interesting architectural details that require few or no cuts.
•
10 %
9 cubes of 3 1/2 in (90 mm)
and 5 1/2 in (140 mm)
for 1 cube of 9 1/2 in (240 mm)
25 %
3 cubes of 3 1/2 in (90 mm)
and 5 1/2 in (140 mm)
for 1 cube of 9 1/2 in (240 mm)
Perfect complement to Cinco or Melville Slik bricks and Permacon
landscaping products.
50 %
1 cube of 3 1/2 in (90 mm)
and 5 1/2 in (140 mm)
for 1 cube of 9 1/2 in (240 mm)
UNITS
A
C
3 1/2 in x 3 1/2 in x variable
3 1/2 in x 9 1/2 in x variable
90 mm x 90 mm x variable
90 mm x 240 mm x variable
(Sold separately)
B
3 1/2 in x 5 1/2 in x variable
90 mm x 140 mm x variable
12 – DESCRIPTIVE DATA SHEET / DUFFERIN® PLUS STONE
MacGuideTecInst16_Eng.indd 12
2016-01-29 9:59 AM
DUFFERIN® PLUS STONE
SIZES – VENEER STONE
7 1/2 in*
(190 mm)
9 1/2 in*
(240 mm)
11 1/2 in*
(290 mm)
13 1/2 in*
(340 mm)
15 1/2 in*
(390 mm)
17 1/2 in*
(444 mm)
9 1/2 in*
(240 mm)
Depth
3 1/2 in*
(90 mm)
5 1/2 in*
(140 mm)
3 1/2 in*
(90 mm)
5 1/2 in*
(140 mm)
Note : *The dimensions are actual. Allow a 3/8 in (10 mm) mortar joint to achieve
the nominal dimensions.
Note : *The dimensions are actual.
DESCRIPTIVE DATA SHEET / DUFFERIN® PLUS STONE – 13
MacGuideTecInst16_Eng.indd 13
2016-01-29 10:00 AM
LAMINA® STONE / MONO LAMINA®
DESCRIPTION
UNITS
The only full bed masonry veneer that offers a stacked stone look. Lamina
A
B
3 1/2 in x 3 3/4 in x 7 3/4 in
3 1/2 in x 3 3/4 in x 11 3/4 in
90 mm x 95 mm x 197 mm
90 mm x 95 mm x 299 mm
C
D
3 1/2 in x 3 3/4 in x 15 3/4 in
3 1/2 in x 3 3/4 in x 19 3/4 in
90 mm x 95 mm x 400 mm
90 mm x 95 mm x 502 mm
stone provides a distinct appearance that enhances your architectural
design through its innovative texture. This multi-length stone offers a
great deal of benefits thanks to its unique design. Its original texture
and colour choices with the addition of Mono Lamina units offer an
enhanced variety to further personnalize and bring out the best in
every project. Lamina stone may be used on your entire facade or just
to accentuate certain architectural elements such as wall sections or
MONO UNITS
skirting.
Characteristics and benefits
•
F
3 1/2 in x 3 3/4 in x 7 3/4 in
3 1/2 in x 3 3/4 in x 11 3/4 in
90 mm x 95 mm x 197 mm
90 mm x 95 mm x 299 mm
G
H
3 1/2 in x 3 3/4 in x 15 3/4 in
3 1/2 in x 3 3/4 in x 19 3/4 in
90 mm x 95 mm x 400 mm
90 mm x 95 mm x 502 mm
An attractive stacked stone appearance thanks to its innovative texture
and stunning colours.
•
A 90 mm thick stone veneer used in a conventional masonry manner.
•
Various stone textures and depths per unit.
•
Easy to install due to its unique single height and its four different
lengths.
•
E
Can be easily combined with our existing Permacon masonry and
landscaping products.
NOTE:
*These dimensions are actual. Allow a 1/4 in (6 mm) mortar joint in order to obtain nominal
dimensions. Lamina stone is offered in a finish that provides the appearance of stacked stones
embellished throughout the years. It is completely normal that some stones present a small
•
Fewer cuts and waste onsite thanks to its modularity.
•
Deeper mortar bed providing a sturdier more durable veneer.
•
Competitive price compared to other masonry systems.
amount of softer edges and rounded corners.
14 – DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA®
MacGuideTecInst16_Ang.indd 14
2016-02-19 11:11 AM
INSTALLATION PATTERN
LAMINA STONE
LAMINA STONE AND MONO LAMINA
(Suggested proportion: 80% Lamina + 20% Mono Lamina)
TYPICAL CROSS SECTION
TYPICAL WOOD STUD WALL
CONSTRUCTION:
TYPICAL CONCRETE BLOCK
WALL CONSTRUCTION:
1/2 in gypsum board
1/2 in gypsum board
1 in wood furring
1 in metal furring
Vapor barrier
Concrete block
2 in x 6 in wood studs
Insulation
with 6 in batt insulation
1 in air gap
Exterior sheeting
3 1/2 Lamina stone
Air-barrier
1 in air gap
3 1/2 Lamina stone
Typical masonry wall ties
Typical masonry wall ties
Flashing
Flashing
10 in foundation wall
10 in foundation wall
DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA – 15
MacGuideTecInst16_Eng.indd 15
2016-01-29 10:00 AM
SPECIFIC INSTALLATION GUIDE
You will notice that the cubes come with all four modules of
Lamina stone.
All of the stones measure 90 mm (3 1/2 in) in actual depth and
95.25 mm (3 3/4 in) in actual height for an easy installation.
Lamina stone is installed like any other masonry veneer.
The units should be installed randomly.
101.6 mm
(4 in)
Incorrect
Each stone has different reliefs. This should be taken into
consideration when installing the stone.
Correct
We suggest the use of mortar in its natural colour so that it
can easily blend into the stone colours. We advise using a
thin jointing tool to achieve a 6 mm (1/4 in) thick joint.
The selection of each stone needs to be as random in length and
texture as possible to achieve a more natural look and feel. Avoid
creating “boxes” while installing, by overlapping the stones at
least 101.6 mm (4 in) to obtain the best interlocking results.
Try to achieve a “mortar joint” of approximately 6 mm (1/4 in)
thick so that you can obtain an equal appearance throughout
the stones.
Forty percent (40%) of the stones have a textured end to easily
achieve corners. They are easily identifiable, always located on
one side of a row on the cube.
In order to make sure that all the mortar joints have the same
color, tool them when they have the same firmness. It should
be noted that the firmer the joints, the darker the colour will
be when tooled.
Once the installation is complete, clean the wall thoroughly with
a stiff brush in order to remove any excess mortar. Remove any
residue in the “inner joint” with a trowel, a thin jointing tool or any
other similar tool. Leave wall to dry for approximately 24 hours
or until completely dry. Wash with any stone or masonry cleaner
recommended by Permacon. Repeat this last step as needed.
inner joints
mortar joints
Identify the “mortar joints” and the “inner joints”.
The basic principle would be to have the “mortar joints”
and “inner joints” as similar in thickness as possible.
back wall
1/4 in
Leave a recessed joint of 6 mm (¼ in) deep compared
to the deepest stone, so that all joints appear equal.
16 – DESCRIPTIVE DATA SHEET / LAMINA® STONE / MONO LAMINA
MacGuideTecInst16_Eng.indd 16
2016-01-29 10:01 AM
CINCO® STONE
DESCRIPTION
INSTALLATION PATTERNS
Cinco stone is truly versatile, due to its six distinct color options and
a look that is part brick, part stone. With a double height and in five
different lengths that are easy to mix and match, Cinco stone can also
be used in design patterns with Cinco brick. Easy to use, Cinco stone
perfectly complements the entire range of Permacon masonry and
landscaping products.
Characteristics and benefits
•
Versatile: use alone or with Cinco Brick.
•
Cost effective (installs like a brick).
•
Unique look that is part brick, part stone.
•
Attractive chiselled texture.
•
Perfect complement to the entire range of Permacon’s masonry and
CINCO STONE AND CINCO BRICK
LINEAR PATTERN
CINCO STONE
LINEAR PATTERN
landscaping products.
UNIT
3 1/2 in x 7 23/32 in x variable
90 mm x 196 mm x variable
CINCO STONE AND CINCO BRICK
MODULAR PATTERN
SIZES
13 5/8 in*
(346 mm)
15 5/8 in*
(397 mm)
17 5/8 in*
(448 mm)
19 5/8 in*
(499 mm)
Depth
3 1/2 in*
(90 mm)
7 23/32 in*
(196 mm)
11 5/8 in*
(295 mm)
Note: *These dimensions are actual. Allow a 3/8 inch (10 mm) mortar joint in order to obtain nominal dimensions.
DESCRIPTIVE DATA SHEET / CINCO ® STONE – 17
MacGuideTecInst16_Eng.indd 17
2016-01-29 10:01 AM
CINCO® BRICK
DESCRIPTION
UNIT
Is it brick or stone? Inspired by buildings constructed at the turn of
3 1/2 in x 3 5/8 in x variable
90 mm x 92 mm x variable
the last century, Cinco brick was created in part to resemble stone.
With its wide array of matched colours and lengths, Cinco brick
creates the perfect accompaniment for Lafitt stone and Cinco stone.
Cinco brick offers you a visual impact at an affordable price. Its unique
height makes the installation similar to brick both in pattern and cost,
while its choice of lengths and textures closely resemble stone. This
product has everything you need to turn your imagination loose.
Characteristics and benefits
•
Combines the best of stone and brick.
•
Harmonizes perfectly with stone, especially Lafitt stone, thanks to its
multiple lengths, texture and colours.
•
Installs like brick so costs are significantly lower than stone.
SIZES (3.2 bricks/ft2)
9 5/8 in*
11 5/8 in*
13 5/8 in*
15 5/8 in*
(194 mm)
(244 mm)
(295 mm)
(346 mm)
(397 mm)
3 5/8 in*
7 5/8 in*
(90 mm)
(92 mm)
Depth
3 1/2 in*
Note: *These dimensions are actual. Allow a 3/8 inch (10 mm) mortar joint in order to obtain nominal dimensions.
18 – DESCRIPTIVE DATA SHEET / CINCO ® BRICK
MacGuideTecInst16_Eng.indd 18
2016-01-29 10:01 AM
MELVILLE® NORMAN BRICK
DESCRIPTION
UNITS
This new, ultra-trendy contemporary brick has long and slender
3 1/2 in x 2 1/4 in x 11 1/2 in
90 mm x 57 mm x 290 mm
proportions. It comes in a smooth finish with sharp edges and its
manufacturing process offers unparalleled dimensional stability for this
brick format.
The result is a modern look with clean lines and an even surface. What’s
more, the colours pair beautifully with Lexa stone and other Permacon
masonry and landscaping products.
Characteristics and benefits
• Choice of trendy colours
•
Manufacturing process offers unparalleled dimensional stability
to the brick
•
Laying with 1/3 running bond pattern avoids cuttiny bricks at the
corner for a more efficient installation
•
Uniform distribution of pigments throughout the bricks that preserve their
colour year after year rather than just on the surface.
SIZES (4.6 bricks/ft2)
3 1/2 in*
(90 mm)
11 1/2 in*
(290 mm)
2 1/4 in*
(57 mm)
Note : *Actual dimensions. Allow 3/8 in (10 mm) mortar joint in order to obtain nominal dimensions.
DESCRIPTIVE DATA SHEET / MELVILLE NORMAN® BRICK – 19
MacGuideTecInst16_Ang.indd 19
2016-02-23 9:09 AM
MELVILLE® SLIK BRICK
DESCRIPTION
UNITS
Melville Slik brick is a classic brick designed to offer major cost benefits
A
B
3 1/2 in x 3 1/8 in x 10 1/8 in
3 1/2 in x 3 1/8 in x 10 1/8 / 8 3/8 in
90 mm x 79 mm x 257 mm
90 mm x 79 mm x 257/212 mm
(materials and installation). Melville Slik brick has a smooth texture with
sharped edges.
Offered in a larger size and available in a wide variety of earth tones,
this versatile urban-style brick can be used alone or in combination with
stone. Melville Slik brick also coordinates perfectly with Permacon’s
masonry and various other landscaping products.
Characteristics and benefits
•
Choice of earth tones and subtle colours.
•
Size lowers overall costs (materials and installation).
•
Holes in the brick make it easier to install and provide increased
adhesion to mortar.
•
Uniform distribution of pigments throughout the brick that preserve
their colour year after year rather than just on the surface.
•
Perfect complement to Dufferin Plus stone and many of Permacon’s
landscaping products to create a stunning overall effect.
SIZES (3.9 bricks/ft2)
3 1/2 in*
3 1/2 in*
(90 mm)
(90 mm)
10 1/8 in*
10 1/8 in*
(257 mm)
(257 mm)
3 1/8 in*
3 1/8 in*
(79 mm)
(79 mm)
8 3/8 in*
(212 mm)
Note: *Actual dimensions. Allow 3/8 in. (10 mm) mortar joint in order to obtain nominal dimensions.
17 percent of the brick on the pallet are in the angled format.
20 – DESCRIPTIVE DATA SHEET / MELVILLE® SLIK BRICK
MacGuideTecInst16_Eng.indd 20
2016-01-29 10:02 AM
URBANIKA® BRICK AND STONE
DESCRIPTION
UNITS
With its generous proportions, lightly chiseled texture, and sharped edges,
Urbanika brick gives your home a clean, contemporary look. Urbanika
A
B
3 1/2 in x 3 1/2 in x 11 7/16 in
3 1/2 in x 7 1/2 in x 15 3/8 in
90 mm x 90 mm x 290 mm
90 mm x 190 mm x 390 mm
stone with a slate-like texture is also available in the same family. It is
ideal for the starting course of a masonry wall, and its modular format
complements Urbanika brick perfectly—making it a valuable asset for
designing projects
Characteristics and benefits
•
Choice of trendy and subtle colours.
•
Size lowers overall costs (materials and installation).
•
Uniform distribution of pigments throughout the brick that preserve
their colour year after year rather than just on the surface.
3 1/2 in*
(90 mm)
SIZES (3.1 bricks/ft2)
3 1/2 in*
(90 mm)
7 1/2 in*
(190 mm)
11 7/8 in*
(290 mm)
3 1/2 in*
(90 mm)
15 3/8 in*
(390 mm)
Note: *Actual dimensions. Allow 3/8 in. (10 mm) mortar joint in order to obtain nominal dimensions.
17 percent of the brick on the pallet are in the angled format.
DESCRIPTIVE DATA SHEET / URBANIKA® BRICK AND STONE – 21
MacGuideTecInst16_Eng.indd 21
2016-01-29 10:02 AM
CARDIFF® ACCESSORIES
DESCRIPTION
This range of ornamental stones will enhance the exterior appearance of
UNITS (SOLD SEPARATELY)
ROCART
CHISELLED
SILL – ROCART
SILL – CHISELLED
5 7/8 in x 36 in x 3 1/2 in
5 7/8 in x 37 3/8 in x 3 1/8 in
150 mm x 914 mm x 90 mm
150 mm x 948 mm x 79 mm
(jamb and lintel)
(jamb and lintel)
Savings on material thanks to its longer sill length, means less cuts
KEYSTONE – ROCART
KEYSTONE – CHISELLED
and waste onsite.
4 1/2 in x 9 7/16 / 4 1/2 in x 12 1/4 in
3 1/2 in x 7 7/8 / 5 7/8 in x 10 1/4 in
115 mm x 240 / 115 mm x 310 mm
90 mm x 200 / 150 mm x 260 mm
your home with a distinctive look. Such features as high density concrete
makes for a durable and aesthetic material. Cardiff accessories with three
finishes available also offer great flexibility for numerous applications.
Characteristics and benefits
•
•
High density concrete makes it more durable.
•
Flexibility and innovation in the design thanks to its RocArt
QUOIN – ROCART
QUOIN – CHISELLED
chiselled and buffed finishes.
3 1/2 in x 23 1/4 in x 12 1/4 in
3 1/2 in x 23 3/8 in x 11 1/2 in
90 mm x 590 mm x 310 mm
90 mm x 593 mm x 290 mm
•
Off white colour that can easily be matched with other colour ranges.
•
The chiselled texture sill, matches the height of a max size brick,
JAMB– CHISELLED
5 1/2 in x 23 3/8 in x 3 1/2 in
such as Melville Slik brick.
•
140 mm x 593 mm x 90 mm
The RocArt finish keystone allows for a one inch (25 mm) projection
while keeping a 90 mm deep mortar bed.
•
The RocArt or buffed finishes sill can also be used as a jamb or lintel.
BUFFED
SILL – BUFFED
BLOCK 400 – BUFFED
5 1/2” X 23 1/4” X 3 1/2”
3 1/2” x 7 1/2” x 15 3/8”
140 mm x 590 mm x 90 mm
90 mm x 190 mm x 390 mm
(jamb and lintel)
BLOCK 600 – BUFFED
RECTANGULAR COPING – BUFFED
3 1/2” x 7 1/2” x 23 1/4”
3 1/2” x 15 3/8” x 23 1/4”
90 mm x 190 mm x 590 mm
90 mm x 390 mm x 590 mm
22 – DESCRIPTIVE DATA SHEET / CARDIFF® ACCESSORIES
MacGuideTecInst16_Ang.indd 22
2016-02-04 2:17 PM
POSSIBILITIES OF APPLICATIONS FOR CARDIFF ACCESSORIES
WINDOW OR DOOR SURROUND
WINDOW OR DOOR SURROUND
CORNER DETAIL
SKIRT WALL
DESCRIPTIVE DATA SHEET / CARDIFF® ACCESSORIES – 23
MacGuideTecInst16_Eng.indd 23
2016-01-29 10:02 AM
Seamless textures and
hatching patterns library
AVAILABILITY CHART
Download all the seamless textures and hatching patterns available
Seamless
textures
Hatching
patterns
•
•
Lafitt Stone
•
•
software: AutoCAD, Dynascape
lexa Stone
•
•
Download Permacon seamless textures for the following types of
Dufferin Plus Stone
•
•
Lamina Stone
•
•
Cinco Stone
•
•
Cinco Brick
•
•
Melville Slik Brick
•
•
Melville Norman Brick
•
•
Urbanika Brick
•
•
Urbanika Stone
•
•
Cardiff Stone
•
N/A
Mondrian Stone
from our website: http://www.permaconpro.ca/pro_support.html
Download Permacon hatching patterns for the following types of
software: AutoCAD, Dynascape, Google Sketchup, Photoshop
24 – SEAMLESS TEXTURES AND HATCHING PATTERNS LIBRARY
MacGuideTecInst16_Eng.indd 24
2016-01-29 10:02 AM
MacGuideTecInst16_Eng.indd 25
2016-01-29 10:03 AM
1-888-PERMACON
PERMACON.CA
PERMACON BOLTON
PERMACON MONTREAL
3 BETOMAT COURT
BOLTON, ONTARIO L7E 2V9
8140, BOMBARDIER STREET
ANJOU, QUEBEC H1J 1A4
TELEPHONE:
FAX:
TELEPHONE:
FAX:
905-857-6773
905-857-4774
514-351-2120
514-351-7454
PERMACON MILTON
PERMACON QUEBEC
8375 5th SIDE ROAD
MILTON, ONTARIO L9T 2X7
8845, PIERRE-BERTRAND BLVD
QUÉBEC, QUEBEC G2K 1W2
TELEPHONE:
FAX:
TELEPHONE:
FAX:
905-875-4215
905-875-1350
418-622-3333
418-622-9603
PERMACON OTTAWA SOUTH
PERMACON SHERBROOKE
6860 BANK STREET
METCALFE, ONTARIO K0A 2P0
1080, PANNETON STREET
SHERBROOKE, QUEBEC J1K 2B4
TELEPHONE:
TELEPHONE:
FAX:
FAX:
613-821-0898
1-800-361-2707
613-821-4593
819-564-1414
819-564-1340
PERMACON TROIS-RIVIÈRES
PERMACON OTTAWA WEST
6775 HAZELDEAN ROAD
STITTSVILLE, ONTARIO K2S 1B9
TELEPHONE:
FAX:
613-821-0898
1-800-361-2707
613-821-4593
C1-C4_MacGuideTecInst16.indd 1
1100, DE LA COMMUNE BLVD
TROIS-RIVIÈRES, QUEBEC G9A 2W6
TELEPHONE:
FAX:
819-378-2721
819-378-6125
2016-01-29 9:53 AM