B.David Company
World Health Through Dynamic Filtration Systems
WP-2000
Pour-Through Water Purification and Filtration System
I N S TA L L AT I O N A N D O P E R AT I N G I N S T R U C T I O N M A N U A L
Patent Pending
FOR SYSTEMS, FILTERS & SERVICE t: 952.884.8417 e: [email protected] w: bdavidwater.com
Rev: 03/09/2017
O P E R AT I O N
A S S E M B LY
1. Place the Filter Connector
IMPORTANT NOTE: If Optional Pre-Filter Net and/
or Filtrations Sleeve are included, put them in place
before adding water by sliding the Filtration Sleeve
over the Purification Cartridge and then stretching
the Pre-Filter Net across the top of the Filter Pail.
on a hard surface with the
threaded end up.
2. Place the threaded portion
of the connecting Adaptor up,
through the hole in the Clean
1. Fill Filler Pail with water from raw water
Water Pail Lid, and then
source. After filling Filter pail, cover
it with the Filter Pail lid.
through the hole in the bottom
of the Filter Pail. (as illustrated)
2. Wait a few minutes for water to
flow through the filters
3. Press down on the bottom
of the Filter Pail (near the hole)
and into the Clean
to expose the threads of the
Connecting Adaptor. Fill the
Gasket over th threads as far
as possible.
NOTE: On
first use, discard the
first two pails of water
produced by the
system. This flushes
Spigot Assembly
FLOW
the Filters.
3. Pull spigot
Clean Water Pail Wall
Gaskets
handle forward
to dispense purified water.
Nut
5. Attach Spigot Assembly to
clean water pail as shown in
diagram.
6. Remove the orange plug from the outlet end
of the Carbon Filter. Place gasket over threads.
FILTER CAPACITIES AND
REPLACEMENT
Nano Filter: 12 months or if
slow flow requires a change
(Part# WP-2003)**
FLOW
4. Screw Pleaded Fibrous
Nano Filter onto Filter Connector (turning clockwise).
Tighten carefully, but be careful not to over-tighten. (Snug
but not so tight as to distort
the shape of the lid.)
Water Pail.
Screw the Carbon Filter into the lower portion of
the Connecting Adaptor (turning clockwise) and
hand tighten.
7. Place Filter Pail with attached filters onto the
Clean Water Pail. Your system is now ready for
use.
Carbon Filter Cartridge:
12 months/1,000 gallons,
or if slow flow rate
requires a change.
(Part# WP-2002)**
FLO
W
FL
O
W
Pre-Filter Gasket: replace when filters are replaced (#180125-4160)
WP-2000 Pour-Through Water Purification and Filtration System
*Patent Pending
Pre-Filter Net (optional): replace when damaged
or worn (Part# WP-2040)
Sleeve for Fibrous Nano Filter: replace when
accumulated dirt cannot be cleaned or
removed or when sleeve restricts flow. (Part#
WP-2050)
**Capacity or life expectancy of the filter cartridges may
vary depending on the quality of the source
water.
2
F I LT E R C H A N G E I N F O R M AT I O N
Replacing the Carbon Filter Cartridge
FLOW
FLOW
FLOW
FLOW
Replacing the Purification Filter
Turn counterclockwise to
loosen and
remove
Turn clockwise
to replace and
tighten
Turn counterclockwise to
loosen and
remove
First Use:
Harmless carbon fibers may be in the water upon
initial use. Discard first two pails to flush filters.
Caution:
DO NOT store the system in direct sunlight or
where wet filters/cartridges can freeze.
DO NOT use with hot water – water over 90º F
Not intended for use with salt water
Turn clockwise
to replace and
tighten
Disclaimer:
The WP-2000 is a personal water purification tool
and should only be used for filtering drinking water.
Any other use of this system is at owner’s risk.
In the unlikely event that the Carbon Filter Cartridge
cracks, throw it away. Do no continue to use it. Do
not try to repair this filter.
AN EXPLODED VIEW OF THE WP-2000*
THE WP-2000*
2-GALLON MINI-BUCKET
A P O U R - T H R O U G H W AT E R
P U R I F I C AT I O N & F I LT R AT I O N
SYSTEM
Filter Pail Lid
Pre-Filter Net
(Optional)
Filter Pail (note:
Hole in bottom)
Filtration Sleeve
(Optional)
Pleated Nano Filter
Nano filter Gasket
Hole in bottom/
center of Filter Pail
Clean Water Pail Lid
(Note: Hole in center)
S P I G O T A S S E M B LY
PA C K A G E
Clean Water Pail
FLOW
Carbon Filter
Gasket
Filter Connector
Carbon Cartridge
Note: Hole for
Spigot
*Patent Pending
WP-2000 Pour-Through Water Purification and Filtration System
3
MAINTENANCE
Date
Activity/Service Performed
B.David Company
World Health Through Dynamic Filtration Systems
Installation Date
Tel: (952) 884-8417
Email: [email protected]
Visit our website: www.bdavidwater.com