Instructions for Micro-Trak NH3 Systems
Used with Raven 440/450 Adapter
Single Section
CONTROL VALVE DELAY
Depress
SPEED until DATA display flashes. The number
CAL shown is the control valve delay digit.
This feature allows the user to set a delay
between the time the booms are turned
ON and when the console begins to control the flow rate. A
value of 1-7 means a delay of 1-7 seconds respectively. A value
of 0 means no delay. This delay is active if the time between
turning OFF and turning ON the booms is less than 30 seconds.
4
Set Raven console valve delay to 7 (MAX). Set Raven VALVE CAL
to 743. This will be a good starting point; if system is unstable or
slow, adjust the Valve Settings as required. See Raven manual for
instructions for setting and adjusting these calibration factors.
The initial control valve calibration number for VALVE CAL
is 743. The VALVE CAL number is used to control response
time of the Control Console to the change in vehicle speed.
After operating the system, this number may be refined.
See Illustration below.
Valve Speed Digit
Valve Backlash Digit
Brake Point Digit
Dead - Band Digit
DATA
FLOW CALIBRATION
Take the Pulses per 10 Gallon figure from the Flowmeter tag
and enter that number into the Raven System. (See Raven
Console Instructions).
RAVEN 440/450 TO MICRO-TRAK
NH3 SYSTEM DIAGRAM
(LIQUIFIER SHOWN)
CONNECTS TO
440/450 CONSOLE
+12 VDC
GROUND
LIQUIFIER
P/N 17582
(120”)
OPTIONAL EXTENSION
CABLE AVAILABLE
IF REQUIRED
(SEE TABLE)
MICRO-TRAK TO 3RD
PARTY ADAPTER CABLE
P/N 17584 (12”)
P/N 17392
P/N 13273
OPTIONAL 10-PIN CABLE
P/N 13220
5’ CABLE
P/N 13221
10’ CABLE
P/N 13222
15’ CABLE
P/N 13223
20’ CABLE
P/N 13224
25’ CABLE
P/N 14142
50’ CABLE
P/N 50279 • Page 1
20 FT.
WAYTEK OUTLET
24”
P/N 13273
WHT
BLACK TIE
120 IN.
20 GA. GRY
20 GA. VIO
20 GA. BLU
20 GA. YEL
20 GA. GRN
16 GA. ORG
16 GA. BLK
16 GA. BRN
16 GA. RED
16 GA. WHT
84”
96”
8”
GREEN TIE
A
C
A 3-PIN NH3 SHUTOFF
B W/P
C SHROUD VALVE
A 3-PIN
B W/P CONTROL
C SHROUD
DISTANCE
FLOW
DUST
COVER B
A 3-PIN
B M/P
C TOWER
GND
SERVO
SERVO
20 GA. GRY
N/C
16 GA. BLK
20 GA. YEL
20 GA. GRN
N/C
16 GA. BRN
N/C
16 GA. RED
N/C
BAND SPLICE &
HEAT SHRINK
A
B
C
10-PIN D
METRI-PACK E
TOWER F
G
BM1
H
J
+12V SW
K
FLOW SIG
BROWN TIE
A 3-PIN
B W/P
C SHROUD
P/N 17582
FLOW SIG
FLOW PWR
FLOW GND
SERVO
SERVO
BM6
BM1
REM/HOLD
(CONS) 12V SW
BM7
BM1
A
B 7-PIN BM2
C METRI-PACK BM3
D MIXED BM4
E TOWER +12V
F
BM5
G
GND
A
B
C
D 10-PIN
E METRI-PACK
F SHROUD
G
H
J
K
18 GA. YEL
18 GA. BRN
18 GA. GRY
18 GA. BLK
10 GA. ORG
18 GA. RED
10 GA. BLU
30A
+12VDC (VBAT)
10 GA. WHT
10 GA. BLK
GND
SPLIT LOOM
BAND SPLICE &
HEAT SHRINK (4)
A 18 GA. RED
FLOW SIGNAL
B 18 GA. WHT
BATTERY +
C 18 GA. BLK
GND
SPEED SIGNAL 10-PIN D 18 GA. RED
SPEED POWER METRI-PACK E 18 GA. WHT
GND 150 TOWER F 18 GA. BLK
G 18 GA. RED
SERVO
H 18 GA. BLK
SERVO
SWITCHED +VES
J 18 GA. RED
GND
K 18 GA. BLK
14 GA. BLU
18 GA. BRN
20 GA. YEL
20 GA. GRN
18 GA. GRY
18 GA. YEL
18 GA. BLK
18 GA. RED
16 GA. ORG
16 GA. BRN
20 GA. BLU
20 GA. VIO
20 GA. GRY
16 GA. RED
16 GA. WHT
14 GA. ORG
BOOM 1
GND 1
BM2 2
SERVO 3
SERVO 4
BM3 5
BM1 6
BM4 7
BM5 8
BM6 9
REM/HOLD 10
FLOW GND 11
+5V FLOW PWR 12
FLOW SIG 13
(CONS) 12V SW 14
BM7 15
+12VDC 16
16-PIN AMP
FEMALE CPC
(206037-1)
To Raven 440/450 Console
12 IN.
BLU
P/N 17584
20 GA. GRY
16 GA. RED
20 GA. BLU
N/C
N/C
N/C
20 GA. GRN
20 GA. YEL
16 GA. BRN
16 GA. BLK
A
FLOW SIG
B
+12V SW
C
FLOW GND
D 10-PIN
E METRI-PACK
F SHROUD
G
SERVO
H
SERVO
J
BM1
K
GND
MIXED COND.
5 - 16.GA / 5 - 20 GA.
Instructions for Micro-Trak NH3 Systems
Used with Raven 440/450 Adapter
Single Section (cont)
P/N 50279 • Page 2
5'
10'
15'
20'
25'
P/N 14146
P/N 14147
P/N 14103
P/N 14236
P/N 14237
CABLE
CABLE
CABLE
CABLE
CABLE
OPTIONAL 7-PIN CABLES
5'
10'
15'
20'
25'
50'
P/N 13220
P/N 13221
P/N 13222
P/N 13223
P/N 13224
P/N 14142
CABLE
CABLE
CABLE
CABLE
CABLE
CABLE
OPTIONAL 10-PIN CABLES
Instructions for Micro-Trak NH3 Systems
Used with Raven 440/450 Adapter
Multi Section
P/N 50279 • Page 3
GND 1
BM2 2
SERVO 3
SERVO 4
BM3 5
BM1 6
BM4 7
BM5 8
BM6 9
REM/HOLD 10
FLOW GND 11
+5V FLOW PWR 12
FLOW SIG 13
(CONS) 12V SW 14
BM7 15
+12VDC 16
14 GA. BLU
18 GA. BRN
20 GA. YEL
20 GA. GRN
18 GA. GRY
18 GA. YEL
18 GA. BLK
18 GA. RED
16 GA. ORG
16 GA. BRN
20 GA. BLU
20 GA. VIO
20 GA. GRY
16 GA. RED
16 GA. WHT
14 GA. ORG
A
B
C
D
E
F
G
A
B
C
D
E
F
G
H
J
K
A
B
C
D
E
F
G
A
B
C
D
E
F
G
H
J
K
P/N 17582
A
B
C
D
E
F
G
A
B
C
D
E
F
G
H
J
K
18 GA. YEL
18GA. BRN
18 GA. GRY
18 GA. BLK
18 GA. ORG
18 GA. RED
18 GA. BLU
20 GA. BRN
20 GA. RED
20 GA. ORG
20 GA. YEL
20 GA. GRN
20 GA. BLU
20 GA. VIO
20 GA. GRY
20 GA. WHT
20 GA. BLK
20 GA. BRN
20 GA. RED
20 GA. ORG
20 GA. YEL
20 GA. GRN
20 GA. BLU
20 GA. VIO
20 GA. GRY
20 GA. WHT
20 GA. BLK
A
B
C
D
E
F
G
H
J
K
SEE TABLE FOR OPTIONAL
EXTENSION CABLES
A
B
C
D
E
F
G
H
J
K
A
B
C
D
E
F
G
18 GA. YEL
18GA. BRN
18 GA. GRY
18 GA. BLK
18 GA. ORG
18 GA. RED
18 GA. BLU
120 IN.
20 GA. GRY
20 GA. VIO
20 GA. BLU
20 GA. YEL
20 GA. GRN
16 GA. ORG
16 GA. BLK
16 GA. BRN
16 GA. RED
16 GA. WHT
18 GA. YEL
18 GA. BRN
18 GA. GRY
18 GA. BLK
10 GA. ORG
18 GA. RED
10 GA. BLU
A
B
C
D
E
F
G
P/N 17739
WAYTEK OUTLET
7-PIN MIXED TOWER
10-PIN M/P SHROUD
20 FT.
7-PIN MIXED SHROUD
10-PIN M/P 150 TOWER
7-PIN MIXED TOWER
10-PIN M/P 150 SHROUD
16-PIN AMP
FEMALE CPC
(206037-1)
7-PIN MIXED SHROUD
10-PIN M/P 150 TOWER
10-PIN M/P 150 SHROUD
7-PIN MIXED TOWER
A
B
C
D
E
F
G
H
J
K
25'
P/N 14237
84”
96”
A 3-PIN
B M/P
C TOWER
YELLOW TIE
P/N 13273
DUST A
COVER B
C
GREEN TIE
A 3-PIN
B M/P
C TOWER
BLACK TIE
P/N 17529
SPLICE AND
HEAT SHRINK
NH3 SHUTOFF
VALVE
BROWN TIE
A 3-PIN
B W/P
C SHROUD
A 3-PIN
B W/P
C SHROUD
CABLE
CABLE
CABLE
CABLE
CABLE
SPLIT LOOM
DISTANCE
20'
P/N 14236
8”
15'
P/N 14103
18 GA. YEL
18GA. BRN
18 GA. GRY
18 GA. BLK
18 GA. ORG
18 GA. RED
18 GA. BLU
10'
P/N 14147
HEAT SHRINK
5'
OPTIONAL 7-PIN CABLES
P/N 14146
18 GA. RED
WHT
18 GA. WHT
18 GA. BLK
18 GA. RED
18 GA. WHT
18 GA. BLK
18 GA. RED
18 GA. BLK
18 GA. RED
18 GA. BLK
A
B
7-PIN M/P C
MIXED D
SHROUD E
F
G
10-PIN M/P 150 TOWER
30A
+12VDC (VBAT)
10 GA. WHT
10 GA. BLK
GND
SPLIT LOOM
BAND SPLICE &
HEAT SHRINK (4)
A 3-PIN
B W/P
SECTION 2
C SHROUD
18 GA. ORG
18GA. BLU
18 GA. BRN
SPLIT LOOM
GREEN TIE
SECTION 2
A 3-PIN
B W/P
C SHROUD
18 GA. ORG
18GA. BLU
18 GA. RED
3-PIN A
W/P DUST B
COVER C
3-PIN A
W/P DUST B SECTION 2
COVER C
A 3-PIN
B W/P
C SHROUD
YELLOW TIE
18 GA. ORG
18GA. BLU
18 GA. BLK
SECTION 2
3-PIN A
W/P DUST B
COVER C
ORANGE TIE
18 GA. ORG A 3-PIN
18GA. BLU B W/P
18 GA. GRY C SHROUD
RED TIE
A 3-PIN
SECTION 1
B W/P
C SHROUD
CABLE
CABLE
CABLE
CABLE
CABLE
CABLE
18 GA. ORG
18GA. BLU
18 GA. YEL
BROWN TIE
50'
P/N 14142
HEAT SHRINK
25'
20'
15'
10'
P/N 13224
P/N 13223
P/N 13222
P/N 13221
5'
OPTIONAL 10-PIN CABLES
P/N 13220
Instructions for Micro-Trak NH3 Systems
Used with Raven 440/450 Adapter
Multi Section (cont)
P/N 50279 © 2017 - 030917 • Page 4