onmentally friendly, economical solution to winter heating
firestart
your environmentally friendly, economical solution to winter heating
your environmentally friendly, economical solution to winter heatin
...Continued
Build a teepee around newsprint or fire sticks and establish a strong coal bed. This is
the first step to firing any type
of wood stove or
fireplace fire.
Caution!
Eco-bricks are a very dry all-wood product. Use only in well
maintained stove or fireplace and control air flow to prevent overheating and extend burn times.
burning Eco-bricks
in stove with rear
combustion chamber
Push coals into mouth of rear combustion chamber, covering it by as much as two-thirds.
your environmentally friendly,
economical solution
to winter heating
burning Eco-bricks in
catalytic stove or stove
with combustion air
tubes in firebox
Start teepee in fire box and establish strong coals.
Push coals to back corner of stove and build wall in front
of and over coal bed, laying Eco-bricks flat and tight
together. Alternate stacking “ECO” insignia facing forward
and sideways to further cut down on air flow through
stack.
Eco-bricks grow slightly when burning.
Do not pack too closely to glass or top lid.
Always maintain some flame in the firebox.
You need to burn the smoke (with flame)
in order to extract heat from the wood.
You should see little or no smoke in the chimney.
Build a wall of bricks in front and over coals, packing
bricks tight together and laying them flat as much as
possible. Stay behind fire irons with fuel.
•
Distributed By:
Once fire is going well close damper to direct air flow
through mouth of rear combustion chamber.
•
•
Continued on back panel...
Walnut Creek Planing | 5778 SR 515 Millersburg, OH 44654
www.ecobrick.net | [email protected]
Ph. 330-893-3244 | Fax 330-893-2468
Manufactured by:
Walnut Creek Planing | 5778 SR 515 Millersburg, OH 44654
www.ecobrick.net | [email protected]
Ph. 330-893-3244 | Fax 330-893-2468
•
Eco Bricks are environmentally friendly, additive free,
compressed hardwood sawdust bricks used for home
heating fuel in wood burning stoves, wood burning
fireplaces, outdoor fire pits, etc.
Clean storage, cost effective
Burns longer than cordwood
BTUs and retail cost of 1-42”x42”x48” skid Eco Bricks =
1-48”x48”x96” cord of well seasoned fire wood.
your environmentally friendly, economical solution to winter heating
your environmentally friendly, economical solution to winter heatin
compared to
32 lbs.
32 lbs of well seasoned (<15% moisture) cordwood
Eco Bricks are equally sized bricks and fit into
wood burning stoves much better than cordwood.
, pressed sawdust fire-
place fuel, is an effective alternative to other fuels
such as fuel oil and coal. Unlike coal and other fossil
fuels that extract CO2 from the ground and deposit
it into the atmosphere when burnt, Eco Bricks are
made from sawdust and are considered CO2 neutral
because the trees they are manufactured from extract more CO2 from the atmosphere than the logs
emit when burnt for heat. As a matter of fact, Eco
Bricks produce 52% less particulate matter to the
atmosphere than cordwood.
700
With Eco-Bricks you have no worries of bugs,
easier storage, much less mess and makes use of
scrap wood which is much more environmentally friendly than cordwood or coal for fuel in wood
burning stoves.
500
200
The results are in!
12:00 PM
6:00 PM
12:00 AM
Eco-bricks burn longer
than the same weight firewood logs.
pressed hardwood
fireplace bricks outperform seasoned hardwood
firewood in burning tests.
Vermont Castings Encore Burning 12
700
Regency® S2400 StepTop Stove Test
600
(Both Tests Used 37 lbs of Wood)
700
600
Stovetop Temp (F)
500
Reduced air
Well seasoned
cordwood
Stovetop Temp (F)
500
No stirring required with
400
300
400
300
200
100
Stirred Cordwood
200
0
0:00
100
3:38
7:12
10:48
14:24
Time
0
4:00 AM
6:24 AM
8:48 AM
11:12 AM
1:36 PM
4:00 PM
Time
Walnut Creek Planing | 5778 SR 515 Millersburg, OH 44654
www.ecobrick.net | [email protected]
Ph. 330-893-3244 | Fax 330-893-2468
300
Time
Eco-bricks are manufactured
from 100% kiln dried
Eco-bricks burn twice as clean as
cordwood leaving ½ as much ash
waste as cordwood.
400
0
6:00 AM
Eco-bricks are a consistent size for easier storage
than cordwood.
1 ton of Eco-bricks = one cord of wood.
1 ton of Eco-bricks = 1 42”x42”x48” skid.
Cord of wood = 48”x48”x96” of storage space.
Eco Bricks take half the storage space but
supply longer burning times due to
density and optimized stove fill.
24,000 lbs pressure making
them twice as dense as cordwood.
Area under curves represents
heat delivered to house!
100
Eco-bricks are twice the density of cordwood
and about the same energy density as coal with
burning times longer than cordwood.
hardwood lumber sawdust and compressed with
Well seasoned
cordwood
600
Stovetop Temp (F)
onmentally friendly, economical solution to winter heating
Walnut Creek Planing | 5778 SR 515 Millersburg, OH 44654
www.ecobrick.net | [email protected]
Ph. 330-893-3244 | Fax 330-893-2468
Ask for new
at your
nearest retail fireplace supply store now
Walnut Creek Planing | 5778 SR 515 Millersburg, OH 44654
www.ecobrick.net | [email protected]
Ph. 330-893-3244 | Fax 330-893-2468
18:09