climbing net - Lowe`s Canada

TM
TM
CLIMBING NET
Age 9+
Safety First!
Use eye protection, always!
Use ear protection with loud power tools
Stay with kids while they work!
Follow tool manufacturers’ safety guidelines
This project is recommended for ages 9+
Page 1
TOOLS
Pencil
Clamps
Drill and drill bits
Scissors
Tape measure
Butane lighter or stick matches
Screw guide accessory for drill (optional)
Yardstick or spare piece of lumber
Page 2
SUPPLIES
Heavy duty twisted nylon rope - (not braided)
Masking tape
Five 3-½-inch [8.9 cm] #8 screws
Five carabiners
Ten eye-bolts - 3/8-inch x 4 inches [0.9 cm x 10 cm]
Eye-bolts
Carabiners
Page 3
Watch the video at: www.lowes.ca/kidsvideos
Overview
Ella's climbing net can be installed indoors or outdoors and it's
incredibly simple to make and hang!
2. Measure
Measure out five vertical rope lengths at 16 feet [487.7 cm] each, and
ten horizontal ropes at 8 feet [243.8 cm] each.
1. Choose
There are so many choices in the rope aisle at Lowe's and we tried all
of them! After seeing how the knots performed in different kinds of
rope, we recommend choosing twisted nylon rope rather than braided
rope because it holds the knots better.
3. Cut
Synthetic rope loves to unravel when its cut, so wrap masking tape
around the rope on either side of the cut before you slice through it
with heavy duty scissors.
Page 4
Watch the video at: www.lowes.ca/kidsvideos
4. Heat
After cutting, melt the ends of the rope to prevent raveling. Be sure to
keep fingers and hands away from the hot nylon!
TIP
You'll need to anchor the vertical ropes to make it easier to tie
multiple knots. You can either tie them off on long partly-sunk screws
(shown below) or you can tie the ropes around a long board to anchor
them. 5. Drill and drive
Drill five evenly-spaced pilot holes in the work surface (12 inches
[30.5 cm] apart) and then partially drive in 3-inch [7.6 cm] screws,
leaving enough height to tie the rope around.
TIP
Use a double overhand knot to tie the vertical ropes to the screws. For
reference, a single overhand knot is the very first step you take in
tying your shoe. To make the double overhand knot, just repeat the
same action of crossing the rope over, around and up. Page 5
Watch the video at: www.lowes.ca/kidsvideos
6. Tighten
Then pull the knot tight to lock it. It forms a pretty figure-8 shape.
7. Mark
Now that you've got your vertical ropes anchored, use chalk to mark
out a grid that will show you exactly where you need to tie the knots
to create your climbing net.
8. Tie
Time to start tying double overhand knots in the vertical ropes at
each junction on the grid. With the first knot, you'll need to pull a LOT
of rope through, then after that the tail will get shorter with each
successive knot.
9. Keep tying
Continue tying knots in the vertical ropes until they're knotted from
top to bottom.
Page 6
Watch the video at: www.lowes.ca/kidsvideos
10. Position the horizontals
Lay out the horizontal ropes across the grid above the existing knots.
11. Secure the horizontal knots in position using the same double
overhand knot, each locked in place by the knots you already tied in
the vertical strands of rope.
TIP
Keep pulling the finished net up until you've completed all of the
horizontal knots. 12. Tie a loop
At the top of each vertical rope, take the excess rope, double it and tie
a single overhand knot which becomes a loop. Page 7
Watch the video at: www.lowes.ca/kidsvideos
13. Attach carabiner
Slip a carabiner through the loop you just made.
14. Repeat
Keep going until you've fastened carabiners to the tops of all five
vertical ropes.
15. Attach
Drill pilot holes and install heavy duty eye-bolts. Space the three
centre eye-bolts one foot [30.5 cm] apart to match the climbing net.
Stretch the two end loops out as far as they can go to help stabilize
the net. Then clip the five carabiners to the eye-bolts.
Tip
Install a few more eye-bolts at the bottom to anchor the net - you'll
probably need a screwdriver passed through the hole of the eye-bolt
to give yourself enough leverage to tighten it completely.
Page 8
Watch the video at: www.lowes.ca/kidsvideos
17. Clip
Clip carabiners onto the eye-bolts at the bottom edge of the net...
...and climb!
Page 9
Watch the video at: www.lowes.ca/kidsvideos
Page 10
DISCLAIMER
Almost any do-it-yourself project involves risk of some sort. Your tools, materials, and skill will vary, as
will the conditions of your project site. Lowe’s Companies Inc., and its subsidiaries ("Lowe’s") have
made every effort to be complete and accurate in the instructions and other content contained in this
publication. However, neither Lowe’s nor the publisher will assume any responsibility or liability for
damages or losses sustained or incurred in the course of your home improvement or repair project or in
the course of your use of the item you create or repair. Always follow the manufacturer’s operating
instructions in the use of tools, check and follow your local building codes, and observe all standard
safety precautions. Prices and supply may vary, so check the cost of materials and labour in your area
before beginning any home improvement project. We strive to be accurate, but unintentional errors may
occur and we reserve the right to correct any error. See a Lowe’s store for information regarding product
warranties and any available protection plans. All prices, products and promotions are limited to Canada
locations only.
This “Family Fun™” video is for informational purposes only. Lowe’s assumes no responsibility for the
accuracy of the information contained herein and disclaims any liability for omissions, errors or the
outcome of any project. Lowe’s assumes no responsibility or liability for damages, losses, or injuries
sustained in the course of your project or in the course of your use of any item you repair or create. Always follow the manufacturer’s operating instructions in the use of tools, and take proper safety
precautions when taking on any project. It is your responsibility to ensure that participants engage in
age-appropriate activities and that children are appropriately supervised. If there is any question or
doubt with regard to any element of a project, please consult with a licensed professional. No part of
this video may be reproduced in any form or by any means without prior written permission of Lowe’s. Lowe’s, the gable design, and Lowe’s Family Fun Projects™ and Learning Through Building are
trademarks of LF, LLC. All rights reserved.
Page 11