MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT GenEon Cleaner and Sanitizer
/23 /12
HMIS
NFPA
0
1
MSDS DATE: 8
0
Personal Protective Equipment
Health Hazard
1
Fire Hazard
0
Reactivity
0
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME:
GenEon Cleaner and Sanitizer
MANUFACTURER:
ADDRESS:
GenEon Technologies, Inc.
16026University Oak
San Antonio, TX 78249
EMERGENCY PHONE:
(866) 217-0205
CHEMICAL NAME:
CHEMICAL FAMILY:
CHEMICAL FORMULA:
Hypochlorous Acid Solution, <1%
Chlorine Compound
HOCl
PRODUCT USE:
Cleaning and Sanitizing and solution
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENT:
Hypochlorous Acid
Sodium Chloride
CAS NO.
7790-93-2
7647-14-5
% WT
<0.005%
<0.3%
ppm
N/A
N/A
OSHA PEL-TWA:
% VOL
N/A
N/A
mg/m3
N/A
N/A
SARA 313 REPORTABLE
No
No
SECTION 3: HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW: Sanitizing solution is considered to be non-hazardous at the use concentration.
TARGET ORGANS:
None known
POTENTIAL HEALTH EFFECTS
EYES:
May produce slight irritation
SKIN:
May produce slight irritation
INGESTION:
May produce slight irritation
INHALATION:
May produce slight irritation
ACUTE HEALTH HAZARDS:
None known
CHRONIC HEALTH HAZARDS:
None known
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
CARCINOGENICITY
OSHA: No
OTHER:
ACGIH: No
None known
NTP: No
PAGE 1 OF 5
None known
IARC: No
MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT GenEon Cleaner and Sanitizer
/23 /12
MSDS DATE: 8
SECTION 4: FIRST AID MEASURES
EYES:
If eyes are irritated, flush eyes with clean, cool water.
SKIN:
If skin is irritated, wash area with soap and water.
INGESTION:
Drink a large glass of water.
INHALATION:
Move to fresh air and seek medical attention, if condition persists.
SECTION 5: FIRE-FIGHTING MEASURES
FLAMMABLE LIMITS IN AIR, UPPER:
(% BY VOLUME)
LOWER:
FLASH POINT:
F:
C:
METHOD USED:
N/A
N/A
AUTOIGNITION TEMPERATURE:
F:
C:
N/A
NFPA HAZARD CLASSIFICATION
HEALTH:
1
FLAMMABILITY:
OTHER:
N/A
0
REACTIVITY:
0
HMIS HAZARD CLASSIFICATION
HEALTH:
1
FLAMMABILITY:
0
REACTIVITY:
0
PROTECTION:
Good safety practices call for the use of safety glasses and protective gloves.
EXTINGUISHING MEDIA:
Use foam or dry chemical if involved in a fire.
SPECIAL FIRE FIGHTING PROCEDURES:
fighting procedures are required.
Solution is not flammable or explosive; no extinguishing media or special fire-
UNUSUAL FIRE AND EXPLOSION HAZARDS:
Solution is not sensitive to mechanical impact or static discharge.
HAZARDOUS DECOMPOSITION PRODUCTS:
None known.
SECTION 6: ACCIDENTAL RELEASE MEASURES
ACCIDENTAL RELEASE MEASURES:
Contain spill with sand or absorbent material and place in sealed bag or container
for disposal. Ventilate and wash spill area after pickup is complete.
SECTION 7: HANDLING AND STORAGE
HANDLING AND STORAGE:
Use with adequate ventilation and do not breathe vapor. Avoid contact with skin, eyes, or
clothing. Wash hands thoroughly after handling. Store in General Storage Area with other items with no specific storage hazards.
Store in a cool, dry, well-ventilated, locked store room away from incompatible materials.
OTHER PRECAUTIONS:
None known.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
VENTILATION :
General room ventilation is usually sufficient.
RESPIRATORY PROTECTION:
Not generally necessary.
PAGE 2 OF 5
MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT GenEon Cleaner and Sanitizer
/23 /12
EYE PROTECTION:
Safety glasses are recommended for best practice.
SKIN PROTECTION:
Protective gloves are recommended for best practice.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
None
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE:
Clear, colorless solution
ODOR:
Slight chlorine odor
PHYSICAL STATE:
Liquid
pH AS PRODUCED:
BOILING POINT:
F:
C:
MELTING POINT:
F:
C:
FREEZING POINT:
F:
C:
VAPOR PRESSURE (mmHg):
@
F:
C:
VAPOR DENSITY (AIR = 1):
@
F:
C:
SPECIFIC GRAVITY (H2O = 1):
@
F:
C:
EVAPORATION RATE:
About 7
SOLUBILITY IN WATER:
Stable solution
PERCENT SOLIDS BY WEIGHT:
<1% by weight
PERCENT VOLATILE:
>99% by weight
212
100
N/A
32
0
N/A
N/A
1.0
68
20
As for water
VOLATILE ORGANIC COMPOUNDS (VOC):
MOLECULAR WEIGHT:
VISCOSITY:
0
52.5
As for water
SECTION 10: STABILITY AND REACTIVITY
STABILITY:
Stable under standard conditions of use and storage
CONDITIONS TO AVOID (STABILITY):
None known
INCOMPATIBILITY (MATERIAL TO AVOID):
None known
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS:
None
HAZARDOUS POLYMERIZATION:
None
PAGE 3 OF 5
MSDS DATE: 8
MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT GenEon Cleaner and Sanitizer
/23 /12
CONDITIONS TO AVOID (POLYMERIZATION):
MSDS DATE: 8
N/A
SECTION 11: TOXICOLOGICAL INFORMATION
TOXICOLOGICAL INFORMATION:
Non-toxic to environment or humans.
SECTION 12: ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION:
viruses and algae.
Not considered an environmental hazard. Destroys bacteria, spores,
SECTION 13: DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD:
RCRA HAZARD CLASS:
No special disposal considerations.
Non-hazardous
SECTION 14: TRANSPORT INFORMATION
U.S. DEPARTMENT OF TRANSPORTATION
PROPER SHIPPING NAME:
HAZARD CLASS:
ID NUMBER:
PACKING GROUP:
LABEL STATEMENT:
Not regulated by DOT
SECTION 15: REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS
TSCA (TOXIC SUBSTANCE CONTROL ACT):
All components are listed
WHMIS CANADA:
Not WHIMIS regulated
CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT):
N/A
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT):
N/A
311/312 HAZARD CATEGORIES:
N/A
313 REPORTABLE INGREDIENTS:
N/A
STATE REGULATIONS:
CA PROPOSITION 65:
Not Listed
SECTION 16: OTHER INFORMATION
OTHER INFORMATION:
This product has been classified in accordance with the haard criteria of the
Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations.
PREPARATION INFORMATION:
Revision 2, August 23, 2012
DISCLAIMER:
All chemicals may pose unknown hazards and should be used with caution. This
Material Safety Data Sheet (MSDS) applies only to the material produced and packaged. If this product is combined with other
materials, deteriorates, or becomes contaminated, it may pose hazards not mentioned in this MSDS. It shall be the user’s
PAGE 4 OF 5
MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT GenEon Cleaner and Sanitizer
/23 /12
MSDS DATE: 8
responsibility to develop proper methods of handling and personal protection based on the actual conditions of use. While this
MSDS is based on technical data judged to be reliable, Geneon Technologies, Inc. assumes no responsiblitiy for the completeness
or accuracy of the information contained herein.
PAGE 5 OF 5