Klarion from Spraying Systems Co. 1
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
KLARION® from Spraying Systems Co.
Safety Data Sheet
Version
Revised
1.2
11-25-2015
1. Product Identification
®
Product name:
Synonyms:
CAS #:
General use:
Formula:
Klarion Sanitizer
Dilute Hypochlorous Acid Solution
Mixture (7790-92-3)
Disinfectant - Sanitizer
H2O + HClO
Manufacturer:
Klarion from Spraying Systems Co.
16815 Southpark Drive
Westfield, IN 46074
1-855-204-8950
Emergency Response Numbers:
24 Hour Emergency 414.277.1311
CHEMTREC Emergency 800.424.9300
2. Hazards Identification
Classification
May be corrosive to metals. The mixture is designed to be safe for skin and eyes, but individual
sensitivities may exist. Protective gloves and goggles are recommended if irritation occurs. The
mixture is a clear liquid with a slight chlorine odor.
Potential Health Effects:
Inhalation:
Insure proper containment of solution and ventilation of area if applicable
Skin:
May cause dryness
Eye:
Prolonged exposure could produce irritation
Ingestion:
Ingestion of large quantities (greater than one liter or one quart) may
produce gastric discomfort, nausea, vomiting or diarrhea
Carcinogenicity:
Active ingredients are not listed by OSHA, EPA, or any other authority as
a carcinogen or tumor promoter
Signal Word:
Hazard Statements:
GHS Pictogram:
Emergency Overview
NONE
NONE
Not Applicable
Page 1 of 6
Klarion from Spraying Systems Co. 2
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
3. Composition and Information on Ingredients
Component Name
Hypochlorous Acid
Water
CAS Number
7790-92-3
7732-18-5
OSHA Hazard EINECS #
Yes
232-232-5
No
% by Weight
.02 %
99.98%
4. First Aid Measures
Eye Contact:
Immediately flush eyes with water for at least 15 minutes while frequently
lifting upper and lower eyelids. Consult a physician if irritation results.
Skin Contact:
Rinse with water. If redness or irritation is severe consult a physician.
Inhalation:
If breathing becomes difficult, or dizziness occurs immediately get to
fresh air – consult a physician if symptoms persist.
Ingestion:
If large quantities of the product are swallowed contact a physician or
poison control center.
5. Fire-fighting Measures
Suitable Extinguishing Media:
Recommended fire extinguishing methods:
Water Spray
Any ABC Class fire extinguisher
Flammability of the Product:
Solution Flash Points:
Auto-Ignition Temperature:
Flammable Limits:
Products of Combustion:
Fire Hazards in Presence of
Various Substances:
Non-flammable
Not applicable – aqueous solution
Not applicable
Not applicable
Not available
Fire Fighting Media and Instructions:
This product is a nonflammable
substance. However, hazardous
decomposition and combustion products
may be formed in a fire situation
especially when the product is used in
conjunction with storage tanks.
General Remarks on Fire Hazards:
Evacuate personnel downwind of fire to
avoid inhalation of irritating and/or
harmful fumes and smoke. Immediately
locate and isolate storage tanks used in
conjunction with this product.
Not applicable
Page 2 of 6
Klarion from Spraying Systems Co. 3
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
6. Accidental Release Measures
Small Spill:
Large Spill:
No special requirement, wash to waste.
Some local environmental regulations may require
neutralization before large amounts are disposed
7. Handling and Storage
Precautions:
Storage:
No special handling required.
If containers are used, insure containers are located in a
well-ventilated area. Use plastic containers.
8. Exposure Controls/Personal Protection
Ventilation:
Respiratory Protection:
Eye Protection:
Protective Clothing:
Good room ventilation is adequate for normal use of this
product.
In accordance with OSHA regulations (29 CFR 1910.134
and 29 CFR 1910.1000) fogging or spraying applications
may require worker respiratory protection.
Good manufacturing practice recommends the use of
chemical safety goggles for all applications involving
chemical handling.
Due to the low concentration and pH, the product is
designed to be safe for skin but individual chemical
sensitivities may exist, therefore protective gloves are
recommended.
9. Physical and Chemical Properties
Physical State and Appearance
Odor
Odor Threshold
pH (.02% solution in water)
Freezing Point
Boiling Point
Flash Point
Evaporation Rate
Flammability (solid, gas)
Upper/lower Flammability or Explosion Limits
Vapor Pressure
Vapor Density
Relative Density
Solubility
Partition coefficient (n-octanol/water)
Auto-ignition Temperature
Decomposition Temperature
Viscosity
Page 3 of 6
Colorless Liquid
Slight Chlorine smell
No Data
4.5 to 6
<0 degrees C
>100 degrees C
Not Applicable
No Data
Not Applicable
Not Applicable
No data
No data
No data
Soluble in water
Insoluble in solvents and oils
No data
Not Applicable
Not Applicable
1.3 cP at 20°C
Klarion from Spraying Systems Co. 4
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
10. Stability and Reactivity Data
Reactivity
Chemical Stability
Possibility of Hazardous
Reactions
Conditions to Avoid
Incompatible Materials
Hazardous Decomposition
Products
The product is an oxidizing compound. Do not mix with
ammonia or strong acids chlorine gas will be produced
The product is stable under normal anticipated
use/storage conditions
Under normal use or storage there is no potential for
hazardous reactions
Extreme heat or freezing.
See reactivity
Excessive heat can produce oxides of chlorine
11. Toxicological Information
Acute Toxicity
Skin Corrosion/Irritation
Eye Damage/Irritation
Carcinogenicity
STOT-Single Exposure
STOT-Repeated Exposure
Aspiration Hazard
No Data
No Data
No Data
No ingredients within this product are listed on the
federal OSHA Z list, EPA, or any other authority as a
carcinogen or tumor promoter.
No Data on this product and its effects on the
reproductive system
No Data
No Data
None
Routes of Entry
Absorbed through skin, eye contact, inhalation, ingestion
Reproductive Toxicity
12. Ecological Information
Toxicity
Persistence and Degradability
Bioaccumulative Potential
Mobility in Soil
Other Adverse Effects
No Data
No Data
No Data
No Data
Due to the low concentration of active
ingredient, and near neutral pH this product is
not expected to be harmful to the environment in
small quantities.
13. Disposal Considerations
Waste Disposal
Follow federal, state, and local regulatory requirements.
May be deactivated with sodium thiosulfate.
Page 4 of 6
Klarion from Spraying Systems Co. 5
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
14. Transport Information
DOT Classification
Corrosive Liquid, acidic, inorganic, N.O.S.
(Hypochlorous Acid)
8
UN3264
II
Corrosive
Hazard Class
Identification Number
Packing Group
Label Required
15. Other Regulatory Information
Federal Regulations:
TSCA Inventory Status – This product or all components
of this product are listed on the EPA/TSCA Inventory of
Chemical Substances.
SARA Title III Section 311/312
Category:
Immediate (Acute) Health Hazard:
Delayed (Chronic) Health Hazard:
Fire Hazard:
Sudden Release of Pressure Hazard:
Reactive Hazard
Yes*
Yes*
No
No
Yes*
*Pertains to HClO in concentrated form. This product
contains HClO in highly diluted form.
SARA Section 302/303/313 HAP
Component
Hypochlorous Acid
RQ (LBS)*1
1000
RQ (LBS)*2 TPQ(LBS)*3 SEC 313*4
N.A.
N.A.
NO
*1 = CERCLA Reportable Quantity
*2 = SARA Reportable Quantity
*3 = SARA EHS Threshold Planning Quantity
HAP*5
NO
*4 = SARA 313 Toxic Chemical/Category
*5 = U.S. EPA Hazardous Air Pollutant
State Regulations: Wisconsin – The following components are listed as a Wisconsin
HAP: Hypochlorous Acid
Page 5 of 6
Klarion from Spraying Systems Co. 6
SDS Klarion Sanitizer (Dilute Hypochlorous Acid Solution)
15. Other Regulatory Information, Continued
HMIS Rating System*
Health
Flammability
Reactivity

NFPA Rating System*
Health
:1
Flammability
:0
Reactivity
:0
Special Hazard : None
:1
:0
:0
Chronic Health Hazard for Hypochlorous acid element in concentrated form.
This product contains Hypochlorous acid in highly diluted form.
16. Other Information
Validated by Tyler Williams
Call 630-517-1744
Notice to Reader:
All chemicals may pose unknown hazards and should be used with caution. This Material Safety Data Sheet (MSDS)
applies only to the material as packaged. If this product is combined with other materials, deteriorates, or becomes
contaminated, it may pose hazards not mentioned in this MSDS. It shall be the user’s responsibility to develop proper
methods of handling and personal protection based on the actual conditions of use. It is the obligation of each user of the
product described in this MSDS to determine and comply with the requirements of all statutes – local, state and federal –
applicable to its use, storage and disposal. While this MSDS is based on technical data judged to be reliable, Spraying
Systems Co. assumes no responsibility for the completeness or accuracy of the information contained herein.
END OF SDS
Page 6 of 6