Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Instruction No
30664463
Version
1.0
Part. No.
Power door mirror with ground lighting
D3500863
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 1 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Equipment
A0000162
A0801450
D8401033
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 2 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
This accessory requires software unique to the car.
Preparations
1
Preparations
Turn the ignition key to position 0
Remove the key from the ignition switch (does not apply to cars
with automatic gearboxes)
Disconnect the battery negative lead.
Note!
Wait at least five minutes before disassembling the connectors
or removing other electrical equipment.
A8800136
Removing the door mirror
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 3 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
2
Removing the door mirror
Carry out steps - on both the left and right-hand sides.
Removing the painted cover
Remove the painted cover (1). Carefully pull the top edge of the
cover backwards and upwards by hand
If the cover is secured too tightly to remove by hand, use a
weatherstrip tool. Insert the weatherstrip tool between the cover
and the surround for the mirror. Pry the cover backwards and
upwards.
D8901741
3A
Illustration A applies to the S60 and the V70 (00-)
Remove:
the cover (1) for the door mirror. Pull the cover straight out
the clips (2). First press in the centre of the clips until a click is
heard
the cover (3) for the door handle. Use a weatherstrip tool
the two screws (4) from under the cover
the door panel. Slide the panel upwards and unhook the top edge
M8502716
the mechanical lock cable and existing connectors. Place the
door panel to one side.
3B
Illustration B applies to the S80
Remove:
the clips (1). First press in the centre of the clips until a click is
heard
the blind cover plug (2) and the screw from under the washer
the surround (3) around the handle carefully. Use a weatherstrip
tool for example
the cover for the door mirror (4). Pull the cover straight out
the door panel (5). First unhook the panel. Then lift the panel out
D8501926
© Volvo Car Corporation
the mechanical lock cable and existing connectors. Place the
door panel to one side.
Power door mirror with ground lighting- 30664463 - V1.0
Page 4 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
4
Disconnect the connector (1)
Remove the nut (2) and the door mirror.
D8301101
5
Transferring the mirror glass, removal
Fold the mirror glass inwards as illustrated
Insert a weatherstrip tool at the inner edge, as illustrated.
Carefully turn / pry while pulling out the outer edge so that the
external catch releases
Work out the glass
Remove the terminal pins from the mirror glass.
D8400383
Installing the door mirror
6
Installing the door mirror
Transferring the mirror glass, installation
Connect the terminal pins to the new mirror glass
Fold out the mirror mounting on the motor
Ensure that both glide rails on the mirror are in the grooves. Hook
the mirror glass into the inner mounting. Press the mirror glass
into place.
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 5 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
D8400370
7
Install the new door mirror. Connect the connector, see point .
8
Reinstall the door panel. See point .
9
Reinstalling the painted cover
Reinstall the rear edge of the cover. Work the cover into place
against the surround
Press the cover in under the surround. Ensure that all hooks click
into place.
Note!
The cover must slide into place with a minimum of force. Do not
attempt to reinstall the cover forcibly.
D8901165
Installing the switch in the panel
10
Installing the switch in the panel
Applies to the S60 and V70 (00-)
Remove the panel in front of the gear selector lever. Carefully
pry off the panel using a plastic weatherstrip tool
Move the gear selector lever as far back as possible.
M8502988
11A
Illustration A applies to the S60, and V70 (00-)
Press in the catches on the front edge of the gear selector lever
panel. Lift the panel upwards, first the front edge and then the
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 6 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
rear edge. Remove the panel around the gear selector lever.
Illustration B applies to the S80
Carefully remove the panel (1) and the boot. Pry carefully using a
weatherstrip tool.
M4302463
11B
D8502224
12A
Illustration A applies to the S60 and the V70 (00-)
Remove the two screws from the dashboard environment panel.
Illustration B applies to the S80
Move the gear selector lever as far back as possible
Pull the panel (1) and the boot as far backwards as possible.
Turn the panel as illustrated
Remove the screws (2) from the dashboard environment panel
(3).
M8503027
12B
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 7 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
D8502684
13
Carefully angle the dashboard environment panel out using a
plastic weatherstrip tool so that it is possible to insert a couple of
fingers to gain access to the side of the dashboard
environmental panel
Remove the dashboard environment panel. Pull it downward,
maintaining the same angle
Disconnect the connectors on the reverse of the dashboard
environment panel.
Note!
If any of the outer hooks break off, these must be repaired.
See the section dealing with the dashboard in VIDA.
M8503045
14
Remove the cigarette lighter
Position the dashboard environmental panel as illustrated
Detach the surround (1) by carefully pushing down the three
catches (2) in the holes (3) using a small screwdriver. At the
same time pry out the surround using a thin weatherstrip tool.
Starting at the 12 volt socket (4), pry up one corner. The
surround is tightly secured so take care not to damage any
components
Remove the surround.
M8503159
15
See the owner's manual for the position of the switch
Remove the switch blank. Install the new switch (1)
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 8 / 9
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Reinstall the surround and the cigarette lighter
Connect the connectors to the dashboard environment panel.
Reinstall the dashboard environment panel. See point Reinstall the panel around the gear selector lever and the panel
in front of the gear selector lever.
D8502226
Finishing work
16
Finishing work
Turn the ignition key to position II
Reconnect the battery negative lead
Program the software according to the service information in
VIDA.
A8800137
© Volvo Car Corporation
Power door mirror with ground lighting- 30664463 - V1.0
Page 9 / 9