Safety Data Sheet
1 - Identification
Product Name: Lava Bar
Product Use: Hand Cleaner
Restrictions on Use: None identified
SDS Date Of Preparation: 08/21/2014
Manufacturer: WD-40 Company
Address:
1061 Cudahy Place (92110)
P.O. Box 80607
San Diego, California, USA
92138 –0607
Telephone:
Emergency only:
1-888-324-7596 (PROSAR)
Information:
1-888-324-7596
Chemical Spills: 1-800-424-9300 (Chemtrec)
1-703-527-3887 (International Calls)
2 – Hazards Identification
Hazcom 2012/GHS Classification:
Eye Irritant Category 2A
Note: This product is a cosmetic product and is labeled in accordance with the US Food and Drug
Administration regulations which take precedence over OSHA Hazard Communication labeling. The actual
container label will not include the label elements below. The labeling below applies to industrial/professional
products.
Label Elements:
WARNING!
Causes serious eye irritation.
Prevention
Rinse hands thoroughly after use.
Response
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to
do. Continue rinsing.
If eye irritation persists: Get medical advice or attention.
3 - Composition/Information on Ingredients
Ingredient
CAS #
Weight Percent
US Hazcom 2012/ GHS
Classification
Not Hazardous
Eye Damage Category 1
Carcinogen Category 2*
Not Hazardous
Pumice
1332-09-8
10-30%
Coconut Acid
Mixture
<3%
Titanium Dioxide
13463-67-7
0.1-1%
Non-Hazardous Ingredients
Mixture
Balance
Note: The exact percentages are a trade secret.
* Carcinogen classification applies to respirable forms only. Not applicable to this product.
4 – First Aid Measures
Ingestion (Swallowed): If large amount is swallowed and symptoms occur, call a physician, poison control
center, or the WD-40 Safety Hotline at 1-888-324-7596. Rinse mouth with water and give one eight-ounce
glass of water to drink if the patient if conscious and responsive.
Page 1 of 4
Eye Contact: Do not rub eyes. Flush immediately with large amounts of water. Get medical attention if
irritation persists.
Skin Contact: This product is intended for skin contact. Discontinue use and consult a physician if irritation
develops and persists.
Inhalation (Breathing): No first aid should be required.
Signs and Symptoms of Exposure: May cause eye irritation.
Indication of Immediate Medical Attention/Special Treatment Needed: Immediate medical attention is not
required.
5 – Fire Fighting Measures
Suitable (and unsuitable) Extinguishing Media: Use any media that is appropriate for the surrounding fire.
Specific Hazards Arising from the Chemical: None known.
Special Protective Equipment and Precautions for Fire-Fighters: None required.
6 – Accidental Release Measures
Personal Precautions, Protective Equipment and Emergency Procedures: None required.
Methods and Materials for Containment/Cleanup: Pick up for use or place in trash.
7 – Handling and Storage
Precautions for Safe Handling: Avoid contact with eyes.
Conditions for Safe Storage: No special storage required.
8 – Exposure Controls/Personal Protection
Chemical
Occupational Exposure Limits
Pumice
5 mg/m3 (respirable), 15 mg/m3 (total dust) OSHA PEL-TWA
Coconut Acid
None Established
Titanium Dioxide
15 mg/m3 (total dust) OSHA PEL-TWA
10 mg/m3 ACGIH TLV-TWA
Non-Hazardous Ingredients
None Established
The Following Controls are Recommended for Normal Consumer Use of this Product
Appropriate Engineering Controls: None required
Personal Protection:
Eye Protection: None required, avoid eye contact.
Skin Protection: None required, this product is intended for skin contact.
Respiratory Protection: None required.
For Bulk Processing or Workplace Use the Following Controls are Recommended
Appropriate Engineering Controls: Good general ventilation should be adequate.
Personal Protection:
Eye Protection: Safety goggles recommended if dust or mists are generated.
Skin Protection: None required for anticipated use, this product is intended for skin contact.
Respiratory Protection: None required.
Work/Hygiene Practices: Rinse thoroughly after washing or handling.
9 – Physical and Chemical Properties
Appearance:
Odor:
Odor Threshold:
pH:
Melting/Freezing Point
Boiling Point/Range:
Green solid
Pleasant Fragrance
Not established
Not Applicable
Not applicable
Not applicable
Flammable Limits:
Vapor Pressure:
Vapor Density:
Relative Density:
Solubilities:
Partition Coefficient; n-
Page 2 of 4
Not applicable
Not applicable
Not applicable
>1
Soluble in water
Not established
Flash Point:
None
Evaporation Rate:
Not applicable
Flammability (solid, gas)
VOC:
Not flammable
0%
octanol/water:
Autoignition
Temperature:
Decomposition
Temperature:
Viscosity:
Pour Point:
Not established
Not established
Not applicable
Not applicable
10 – Stability and Reactivity
Reactivity: Not reactive under normal conditions
Chemical Stability: Stable
Possibility of Hazardous Reactions: None known.
Conditions to Avoid: None known.
Incompatible Materials: None known.
Hazardous Decomposition Products: Combustion will produce oxides of carbon and nitrogen.
11 – Toxicological Information
Symptoms of Overexposure:
Inhalation: None known
Skin Contact: Prolonged contact may cause irritation in sensitive individuals.
Eye Contact: May cause irritation with redness, stinging and tearing. Pumice may cause abrasive injury to
the eye.
Ingestion: Not intended for ingestion, however, not expected to be toxic. May cause gastrointestinal irritation.
Chronic Effects: None known.
Carcinogen Status: This product contains small amount of titanium dioxide, which is listed by IARC as a
suspected carcinogen (Group 2B). Titanium dioxide only presents a risk of cancer by inhalation of very fine
dust. In this product, the titanium dioxide is incorporated into the soap and is not present as a respirable dust.
There is no exposure to respirable titanium dioxide dust in the normal use of this product. None of the other
components are listed as a carcinogen or suspect carcinogen by IARC, NTP, ACGIH or OSHA.
Reproductive Toxicity: None of the components is considered a reproductive hazard.
Numerical Measures of Toxicity:
The oral toxicity of this product is estimated to be greater than 5,000 mg/kg and the dermal toxicity greater
than 2,000 mg/kg based on an assessment of the ingredients. This product is not classified as toxic by
established criteria.
12 – Ecological Information
Ecotoxicity: No specific aquatic toxicity data is currently available, however components of this product are
not expected to be harmful to aquatic organisms
Persistence and Degradability: No data available.
Bioaccumulative Potential: No data available.
Mobility in Soil: No data available
Other Adverse Effects: None known
13 - Disposal Considerations
Dispose in accordance with local, state and federal regulations.
14 – Transportation Information_
Not regulated for Transportation by any mode
15 – Regulatory Information
U.S. Federal Regulations:
Page 3 of 4
CERCLA 103 Reportable Quantity: This product is not subject to CERCLA reporting requirement. Many
states have more stringent release reporting requirements. Report spills required under federal, state and
local regulations.
SARA TITLE III:
Hazard Category For Section 311/312: Acute Health
Section 313 Toxic Chemicals: This product contains the following chemicals subject to SARA Title III
Section 313 Reporting requirements: None
Section 302 Extremely Hazardous Substances (TPQ): None
EPA Toxic Substances Control Act (TSCA) Status: All of the components of this product are listed on the
TSCA inventory.
California Safe Drinking Water and Toxic Enforcement Act (Proposition 65): This product does not
contain chemicals regulated under California Proposition 65.
This MSDS has been prepared according to the criteria of the Controlled Products Regulation (CPR) and the
MSDS contains all of the information required by the CPR.
16 – Other Information:
HMIS Hazard Rating:
Health – 1 (slight hazard), Fire Hazard – 0 (minimal hazard), Physical Hazard – 0 (minimal hazard)
Revision Date: August 21, 2014
Supersedes: January 8, 2009
Revision Summary: Convert to Hazcom 2012. Changes in all sections.
Prepared by: Industrial Health & Safety Consultants, Inc. Shelton, CT, USA
APPROVED By: I. Kowalski
Regulatory Affairs Dept.
3042200/No.0098003
1097000/No.0098003
Page 4 of 4