READ THESE INSTRUCTIONS COMPLETELY BEFORE STARTING WORK.
IF YOU DON'T UNDERSTAND CALL 1-888-523-3371 FOR ASSISTANCE.
INSTRUCTIONS: (Continued)
TOP
TOP
TOP RUNG
TIE OFF
ROPE INSTALLATION INSTRUCTIONS
TOP SINGLE
PULLEY
FLY
SECTION
WARNING:
1. Failure to comply with all instructions may result in serious injury.
BASE
SECTION
2. Make sure this kit fits your ladder. If you have any questions concerning the use of this kit on other Werner Co. products,
call 1-888-523-3371 for assistance.
BASE
SECTION
TOP RUNG
TIE OFF
FLY
SECTION
INTERNAL FLY
(INTERMEDIATE
SECTION)
TOP DOUBLE PULLEY
TOP SINGLE
PULLEY
3. Before installing this kit, identify all kit components. If any components are missing or damaged, return the kit to place of
purchase. Do not substitute any components.
4. Inspect the ladder before installing this kit. Repair or replace any damaged or missing ladder parts before using the
ladder. Use only Werner Co. repair or replacement parts. If unable to repair, discard the ladder.
ROPE
INSTALL ROPE THE SAME AS EXISTING ROPE.
INSTALL AS SHOWN IN ILLUSTRATIONS
THEN TRIM AS DIRECTED BELOW.
TRIM NOTE: With ladder sections assembled, trim rope at second rung as shown.
(Sections shown separated for clarity.) Follow instructions for trimming rope below.
For Polypropylene and Polyester Ropes —
Wrap area to be cut with masking tape to hold
strands in place. Cut rope, then with match,
melt cut ends of rope to prevent fraying.
For Manila Rope —
Wrap area to be cut (2" Wide) with electrical
tape then cut through center of tape to
prevent fraying. Leave tape in place.
INSTRUCTIONS:
All fiberglass extension and aluminum
extension ladders with single pulley
rope assembly.
ROPE
SEE TRIM
NOTE ON
OTHER SIDE
BOTTOM
SINGLE
PULLEY
BOTTOM
DOUBLE
PULLEY
BOTTOM
RUNG TIE
OFF
BOTTOM
BOTTOM
Models 7536, 7540, D7536, D7540, D536, D540, D544,
D548, 544 and 548 ladders with double pulley rope
assemblies
NOTE: Rung may be D - Rung
Model 560-3
TOP
BASE
SECTION
TOP SINGLE
PULLEY
FLY
SECTION
TOP SINGLE PULLEY
TOP RUNG TIE OFF
TOP DOUBLE PULLEY
BOTTOM RUNG TIE OFF
BOTTOM SINGLE PULLEY
BOTTOM DOUBLE PULLEY
ROPE
BOTTOM
RUNG TIE
OFF
BOTTOM
SEE TRIM
NOTE
ABOVE
WERNER CO., 93 WERNER ROAD, GREENVILLE, PA 16125-9499
PHONE 1-888-523-3371
P/N 48423-01 © 2012 Werner Co. Rev E 5/12
www.wernerco.com