Fisher Engineering
PLOW ASSEMBLY
RIGHT SIDE PLOW LAMP
RED
T
BRN
P
P/T SIG
T
P
RED
PUR
BRN
BRN
TO VEHICLE
HEADLAMPS
BLU (GND)
BLU (GND)
RED (HIGH)
GRN (HIGH)
ORN (LOW)
YEL (LOW)
HEADLAMP
WHT
BLK/ORN
BLK
H
L
May 1998
No. 22372
COMPONENTS LOCATED NEAR FRONT OF VEHICLE
TO RIGHT TURN
LAMP BULLET
HIGH
BEAM
RELAY
LOW
BEAM
RELAY
PUR
TO LEFT TURN
LAMP BULLET
GRY
ORN 87A
BLK 87
30
YEL
RED 87A
WHT 87
30
GRN
TO PARK
LAMP BULLET
BRN
BRN 86
85
BLK/ORN
BRN 86
85
BLK/ORN
Headlamp Electrical Schematics
for Straight Blades
BLK/ORN
(GROUND)
87
86
#6 BLK
BLK
BLK/ORN
WHT
P
T
P/T SIG
P
T
BRN
BRN
RED
GRY
BRN
RED
LEFT SIDE PLOW LAMP
#6 BLK/RED
#6 BLK
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
GRY
PUR
BRN
RED
IGNITION
2
RED
1
4
2
5
3
6
LT GRN
ORN/BLK
BRN/RED
LT BLU
WHT/YEL
BRN
3
BLK
BLU
RED
*REPRESENTATION
4
OF PRINTED
CIRCUIT BOARD
5
6
LOCATED UNDER DASH
1
2
3
4
5
#6 BLK/RED
#6 BLK
*SOLENOID
CONTROL
GRN
6
BLU
RED
YEL
ORN
GRN
WHT
BLK
**HAND HELD
CONTROL
1
2
3
4
5
6
7
COIL CORD HARNESS
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK
BRN/RED
MTR RLY
#6 RED
12V BATTERY
PUMP MOTOR
- M + #6 BLK/RED
1
2
3
4
5
6
7
8
9
10
11
12
PUR
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
PUR
BLK/ORN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
WHT/YEL
H
SFE6
LOCATED AT FRONT OF VEHICLE
LT GRN
L
WHT
1
BLK/ORN
S3 SOLENOID
LT BLU
S1 SOLENOID
85
TERMINAL
LOCATIONS
BLK (LOW BEAM)
S2 SOLENOID
87A
30
WHT (HIGH BEAM)
HEADLAMP
FROM VEHICLE
HEADLAMP
CONNECTOR
1
2
3
4
5
6
7
**REPRESENTATION
OF PRINTED
CIRCUIT BOARD
Contents
Headlamp Type
Harness Type
DRLs
(Yes/No)
Page No.
Electrical Legend and Wire Colors ......................................................... 5
2E
9-Pin, C
No
16
Electrical Connectors .............................................................................. 6
2E
9-Pin, C
Yes
20
Electrical Schematic – 9-Pin Vehicle Harness ....................................... 7
2E
12-Pin, B
Yes
27*
Electrical Schematic – 9-Pin Vehicle Harness – Rev. 1-9 ...................... 8
HB1
7-Pin, A
No
12
HB1
7-Pin, A
Yes
13
7-Pin Harness - Plow Schematic ........................................................... 11
HB1
9-Pin, A
No
15
9-Pin Harness - Plow Schematic .......................................................... 14
HB1
9-Pin, A
Yes
21
12-Pin Harness - Plow Schematic ........................................................ 23
HB1
9-Pin, C
No
16
12-Pin Harness - Plow Schematic (Nissan and Toyota) ...................... 30
HB1
9-Pin, C
Yes
20
Headlamp Index
HB1
12-Pin, A
No
25
HB1
12-Pin, A
Nissan w/ and
w/o DRLs;
Toyota w/DRLs)
31
Lamp Types and Harness Connectors ................................................... 4
Electrical Schematic – 12-Pin Vehicle Harness ..................................... 9
Electrical Schematic – 12-Pin Vehicle Harness – Rev. 1-7 .................. 10
Headlamp Type
Harness Type
DRLs
(Yes/No)
1A/2A
9-Pin, A
No
18
1A/2A
9-Pin, C
No
22
2B/2D
9-Pin, A
No
15
2B/2D
9-Pin, A
Yes
21
2B/2D
9-Pin, C
No
16
2B/2D
9-Pin, C
Yes
20
2B/2D
12-Pin, A
Nissan w/ and
w/o DRLs;
Toyota w/ DRLs
31
Page No.
HB3/HB4
9-Pin, A
No
17
HB3/HB4
9-Pin, A
Yes
19
HB3/HB4
12-Pin, B
Yes
28
HB3/HB4
12-Pin, D
Yes (Automatic,
DRL kit not
required)
26
HB5
7-Pin, A
No
12
HB5
7-Pin, A
Yes
13
HB5
9-Pin, A
No
15
2B/2D
12-Pin, B
No
24
HB5
9-Pin, A
Yes
21
2B/2D
12-Pin, B
Yes
27
LF/UF
12-Pin, B
Yes
29
* Early GM applications used two harnesses spliced together.
No. 22372
2
May 1998
INTRODUCTION
EARLY REVISION VEHICLE HARNESSES
The purpose of this book is to provide the trained
mechanic with a comprehensive reference to
assist in diagnosis and repair of FISHER®
Minute Mount® snowplow electrical systems. It
contains schematics, diagrams and charts which
supply information for the various types of vehicle
and plow headlamp systems. Although intended
primarily as a diagnostic tool for headlamp
systems, the straight blade hydraulic system
circuitry is also included to show the complete
electrical system.
All 9- and 12-pin vehicle harnesses are labeled
with a white tag indicating the harness part
number and revision level. Early 9-pin harness
revisions 1-9 and 12-pin harness revisions 1-7
have a ground circuit in which the control, motor
relay, and headlamp relays all ground through the
9- or 12-pin connector. Some of these early
revision harnesses also have a diode in the
ground wire to the headlamp relays. Complete 9and 12-pin system schematics showing this early
revision ground configuration are included in the
front of the book. These schematics are for early
revision harnesses using only the solenoid
control. If a hand-held control has been installed,
the ground circuit has been modified into the later
revision configuration, in which only the headlamp
relays ground through the 9- or 12-pin connector
and the control and motor relay ground separately
to the battery. Early revision harnesses may be
easily identified by a single black/orange wire on
one of the motor relay primary terminals which
does not continue on to the negative battery
terminal. All vehicle side schematics in this book
show only the later revision circuitry.
HOW TO USE THIS BOOK
Use the information in the Table of Contents to
locate the electrical schematic for the vehicle. All
headlamp harnesses are tagged with the harness
part number. The schematic is an abstract
drawing showing the purpose of each component
in the system. Where possible, component
locations are indicated by enclosures on the
schematic. The Lamp Type, Wire Color and
Connector Identification charts and diagrams will
give specific wire colors, their function and
locations in connectors. Any special notes are
found in the upper right corner of the schematic.
Further information and a specific troubleshooting
guide may be found in the Mechanic’s Guide for
the SEHP system.
NOTE: To verify the correct light kit/plug-in
harness on a particular vehicle, refer to the
appropriate Kit Selection Guide.
The 9- and 12-pin Vehicle Side schematics
contain all vehicle headlamp and harness types.
The 7-pin Vehicle Side Schematics show only a
few representatives applications. For other 7-pin
vehicle headlamp and harness types, refer to the
corresponding 9-pin Vehicle Side schematic and
use only the headlamp circuitry.
No. 22372
3
May 1998
Lamp Types and Harness Connectors
LAMP TYPE
LAMP SIZE
1A / 2A
4″ x 6.5″
Quad Rectangular Lamp
NOTE: The lamp type
is usually embossed in
the headlamp lens.
2B
5.5″ x 7.88″
Dual Rectangular Lamp
7″ DIA.
Dual Round Lamp
2E
4″ x 6.5″
Dual Rectangular (Small Halogen Lamp)
HB1
Can Vary
Dual Rectangular Halogen Lamp
HB3 / HB4
Can Vary
Quad Composite Halogen Lamp
HB5
Can Vary
Dual Rectangular Halogen Lamp
LF / UF
3.64″ x 5.93″
Quad Rectangular Halogen Lamp
2B/2D
GROUND
LOW
HIGH
RED (HIGH)
BLUE (GND)
BLUE (GND)
LOW
YELLOW (LOW)
GROUND
LF / UF
BLUE (GND)
YELLOW (LOW)
HIGH
GROUND
LOW
GREEN (HIGH)
YELLOW (lOW)
BLUE (GND)
GROUND
BLUE (GND)
ORANGE (LOW)
RED (HIGH)
HIGH
HIGH
GROUND
GREEN (HIGH)
BLUE (GND)
YELLOW (LOW)
BLUE (GND)
GREEN (HIGH)
BLUE (GND)
ORANGE (LOW)
BLUE (GND)
YELLOW (LOW)
4
HIGH
LOW
GREEN (HIGH)
BLUE (GND)
LOW
GROUND
RED (HIGH)
BLUE (GND)
RED (HIGH)
ORANGE (LOW)
GREEN (HIGH)
YELLOW (LOW)
BLUE (GND)
HB5
GROUND LOW
GROUND
HIGH
HIGH
BLUE (GND)
No. 22372
RED (HIGH)
ORANGE (LOW)
BLUE (GND)
BLUE (GND)
RED (HIGH)
LOW
GROUND
NOTE: Blue ground wires
may be LT or DK BLU, w/ or
w/o WHT stripe, depending
on harness.
GROUND
LOW
HB3 / HB4
GROUND
GROUND
HIGH LOW
LOW
HIGH
RED (HIGH)
BLUE (GND)
ORANGE (LOW)
GREEN (HIGH)
YELLOW (LOW)
BLUE (GND)
GROUND
GREEN (HIGH)
GROUND
HIGH
HB1
2E
HIGH
YELLOW (LOW)
GROUND
BLUE (GND)
LOW
DESCRIPTION
2D
ORANGE (LOW)
BLUE (GND)
RED (HIGH)
1A/2A
GROUND
CONFIGURATION
May 1998
Electrical Legend and Wire Colors
Electrical Legend
CROSSING WIRE
WIRE SPLICE
IN LINE CONNECTOR
RING TERMINAL
FUSE
S1 = SV08-2004
SOLENOID S2 = SV08-30
S3 = SV08-40
+
Black
LTBLU
Light Blue
BLK/ORN
Black w/ Orange
LTBLU/ORN
Light Blue w/ Orange
BLK/RED
Black w/ Red
LTBLU/WHT
Light Blue w/ White
BLK/WHT
Black w/ White
LTGRN
Light Green
BLU
Blue
ORN
Orange
BLU/ORN
Blue w/ Orange
ORN/BLK
Orange w/ Black
BRN
Brown
PNK
Pink
BRN/RED
Brown w/ Red
PUR
Purple
DKBLU
Dark Blue
RED
Red
DKBLU/ORN
Dark Blue w/ Orange
TAN
Tan
DKBLU/WHT
Dark Blue w/ White
WHT
White
GRN
Green
WHT/YEL
White w/ Yellow
CIRCUIT GROUND
GRN/WHT
Green w/ White
YEL
Yellow
GRY
Gray
BATTERY
M
BLK
DIODE
MOTOR RELAY
–
Wire Color Code
Abbreviations
DRL
Daytime Running Lights
MTR RLY
Motor Relay
MOTOR
Harness
Type
PARK /TURN LAMP
HEADLAMP
Description
A
Common Ground to headlamps
B
GM DRL system
C
Independent Ground to headlamps
D
GM Enhanced DRL system
COMPONENT ENCLOSURE
No. 22372
5
May 1998
Electrical Connectors
Harness Connectors
Plow (end view)
7
Headlamp Relay
Terminal Locations
1
87A
9 10 11 12
85
2
3
4
5
6
Vehicle (end view)
30
1
2
3
4
5
6
7
8
9 10 11 12
(sockets)
NOTE: The 7-, 9- and 12-pin
harness connector pin #’s are
embossed in the molded plug.
7-Pin
9-Pin
12-Pin
Control Function
—
Valve S1(2W)
White/Yellow
White/Yellow
Blacka
Blacka
Black
Low Beam 9/12-Pin Rt
—
Valve S2(3W)
Lt Green
Lt Green
—
Valve S3(4W)
Lt Blue
Lt Blue
Black/Orangec Black/Orangec,d Black/Orangec,d
Ground
White
White
White
High Beam
—
—
Black/White
Low Beam 12-Pin Lt
—
—
Dk Blue/Orange Gnd Low Beam 12-Pin Rt
Gray
Gray
Gray
Left Directional
Purple
Purple
Purple
Right Directional
Brown
Parking Lights
Brown
Brown
b
—
Lt Blue/Orange Gnd Low Beam 12-Pin Lt
Orange/Black
1
2
3
4
5
6
7
8
9
10
11
12
(pins)
87
86
8
Wire Color
Pin #
a LEFT AND RIGHT SIDES.
b 7-PIN SYSTEM — MAIN GROUND.
c GROUND FOR HEADLIGHT RELAYS ONLY.
d ON EARLY REVISION HARNESSES, BLACK/ORANGE WIRE IS
GROUND FOR MOTOR RELAY, CONTROL AND HEADLIGHT
RELAYS.
Control Connectors
Control Side
(end view)
6
3
5
2
4
1
(pins)
No. 22372
Vehicle Side
(end view)
Pin # Solenoid Control
Wire Color Only
1
2
3
4
5
6
White
Green
Brown
Black
Blue
Red
3
6
2
5
1
4
(sockets)
6
Pin #
Wire Color
Control Function
1
2
3
4
5
6
Red
Lt Green
Orange/Black
Brown/Red
Lt Blue
White/Yellow
+12V
S2(3W)
Ground
Motor Relay
S3(4W)
S1(2W)
May 1998
Electrical Schematic – 9-Pin Vehicle Harness
PLOW ASSEMBLY
RIGHT SIDE PLOW LAMPS
T
P
T
P
COMPONENTS LOCATED NEAR FRONT OF VEHICLE
RED
BRN
RED
PUR
BRN
BRN
WHT
BLK/ORN
BLK
H
L
TO VEHICLE
HEADLAMPS
BLU (GND)
BLU (GND)
RED (HIGH)
GRN (HIGH)
PUR
TO LEFT TURN
LAMP BULLET
GRY
TO PARK
LAMP BULLET
BLK/ORN
(GROUND)
YEL (LOW)
ORN (LOW)
TO RIGHT TURN
LAMP BULLET
HIGH
BEAM
RELAY
LOW
BEAM
RELAY
ORN 87A
BLK 87
30 YEL
BRN 86
85 BLK/ORN
BRN
RED 87A
WHT 87
30 GRN
BRN 86
85 BLK/ORN
87
86
PUMP MOTOR
- M + #6 BLK/RED
BLK
BLK/ORN
WHT
T
P
T
BRN
BRN
RED
GRY
RED
2
RED
1
4
2
5
3
6
LT GRN
BLK/ORN
BRN/RED
GRY
PUR
BRN
LT BLU
WHT/YEL
GRN
BRN
3
BLK
BLU
RED
*REPRESENTATION
4
OF PRINTED
CIRCUIT BOARD
5
6
LOCATED UNDER DASH
1
2
3
4
5
#6 BLK/RED
#6 BLK
6
BLU
RED
YEL
ORN
GRN
WHT
BLK
**HAND HELD
CONTROL
1
2
3
4
5
6
7
COIL CORD HARNESS
1
2
3
4
5
6
7
**REPRESENTATION
OF PRINTED
CIRCUIT BOARD
LOCATED NEAR BATTERY
#6 BLK/RED
BLK/ORN
BRN
LEFT SIDE PLOW LAMPS
No. 22372
#6 BLK/RED
#6 BLK
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
RED
IGNITION
*SOLENOID
CONTROL
NOTE: All relays are shown
in the de-energized state.
7
#6 BLK
BRN/RED
MTR RLY
#6 RED
12V BATTERY
WHT/YEL
1
2
3
4
5
6
7
8
9
10
11
12
PUR
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
PUR
BLK/ORN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
#6 BLK
P
SFE6
LOCATED AT FRONT OF VEHICLE
LT GRN
H
WHT
1
BLK/ORN
S3 SOLENOID
LT BLU
L
85
TERMINAL
LOCATIONS
WHT (HIGH BEAM)
S1 SOLENOID
87A
30
BLK (LOW BEAM)
S2 SOLENOID
FROM VEHICLE
HEADLAMP
CONNECTOR
May 1998
Electrical Schematic – 9-Pin Vehicle Harness – Revision 1-9
PLOW ASSEMBLY
RIGHT SIDE PLOW LAMPS
T
P
T
P
COMPONENTS LOCATED NEAR FRONT OF VEHICLE
RED
BRN
RED
PUR
BRN
BRN
WHT
BLK/ORN
BLK
H
L
TO VEHICLE
HEADLAMPS
BLU (GND)
BLU (GND)
RED (HIGH)
GRN (HIGH)
PUR
TO LEFT TURN
LAMP BULLET
GRY
TO PARK
LAMP BULLET
BLK/ORN
(GROUND)
YEL (LOW)
ORN (LOW)
TO RIGHT TURN
LAMP BULLET
FROM VEHICLE
HEADLAMP
CONNECTOR
HIGH
BEAM
RELAY
LOW
BEAM
RELAY
BRN
ORN 87A
BLK 87
30
BRN 86
85
YEL
BLK/ORN
RED 87A
WHT 87
30
BRN 86
85
87
GRN
86
BLK/ORN
87A
85
30
TERMINAL
LOCATIONS
WHT (HIGH BEAM)
BLK (LOW BEAM)
DIODE
REV. 7-9
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
LT GRN
WHT/YEL
PUMP MOTOR
- M + #6 BLK/RED
#6 BLK
BLK
BLK/ORN
WHT
L
H
P
T
P
T
BRN
BRN
RED
GRY
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
RED
RED
IGNITION
RED
LT GRN
BLK/ORN
BRN/RED
LT BLU
WHT/YEL
1
1
2
2
3
3
4
4
5
5
6
6
WHT
*SOLENOID
CONTROL
GRN
BRN
BLK
BLU
RED
*REPRESENTATION
OF PRINTED
CIRCUIT BOARD
LOCATED UNDER DASH
#6 BLK/RED
#6 BLK
LOCATED NEAR BATTERY
#6 BLK/RED
BRN
LEFT SIDE PLOW LAMPS
No. 22372
#6 BLK/RED
#6 BLK
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
PUR
S1 SOLENOID
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
PUR
BLK/ORN
S2 SOLENOID
SFE6
LOCATED AT FRONT OF VEHICLE
BLK/ORN
NOTE: All relays are shown
in the de-energized state.
8
#6 BLK
BRN/RED
MTR RLY
#6 RED
12V BATTERY
BLK/ORN
S3 SOLENOID
LT BLU
May 1998
Electrical Schematic – 12-Pin Vehicle Harness
COMPONENTS LOCATED NEAR FRONT OF VEHICLE
PLOW ASSEMBLY
ORN (LOW)
RIGHT SIDE PLOW LAMPS
RED
BRN
TO TURN LAMP
BULLET
GRY
ORN (LOW)
YEL (LOW)
TO LEFT SIDE
VEHICLE
HEADLAMPS
RED (HIGH)
GRN (HIGH)
WHT
DK BLU/ORN
BLK
H
L
DK BLU/ORN-RIGHT
LT BLU/ORN-LEFT
(GROUND)
WHT(HIGH BEAM)
BLK/ORN
S1 SOLENOID
M
+
P
WHT/YEL
#6 BLK/RED
T
P
T
BRN
RED
#6 BLK/RED
#6 BLK
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
RED 87A
87
PNK 86
LT BLU/
WHT 87A
LT BLU/ 87
ORN
PNK 86
30 GRN
85 BLK/ORN
DRL KIT WIRE
3AG5
PNK
SFE6
30 LT BLU
87
85 BLK/ORN
WHT
1
86
87A
85
BRN
3
LT GRN
BLK/ORN
BRN/RED
LT BLU
WHT/YEL
BLK
4
BLU
5
1
RED
6
2
*REPRESENTATION
OF PRINTED
CIRCUIT BOARD
3
4
BLU
1
5
RED
2
6
LOCATED UNDER DASH
YEL
3
ORN
4
GRN
5
#6 BLK/RED
#6 BLK
TERMINAL
LOCATIONS
*SOLENOID
CONTROL
GRN
2
RED
IGNITION
RED
WHT
6
BLK
**HAND HELD
CONTROL
1
2
3
4
5
6
7
COIL CORD HARNESS
1
2
3
4
5
6
7
**REPRESENTATION
OF PRINTED
CIRCUIT BOARD
LOCATED NEAR BATTERY
BRN
BLK/ORN
GRY
#6 BLK/RED
BLK/ORN
BRN
RED
LEFT
SIDE
RELAY
VEHICLE
HIGH BEAM
RELAY
30
PUR
LT GRN
BLK/WHT
LT BLU/ORN
WHT
H
BRN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
#6 BLK
L
TO PARK LAMP
BULLET
RIGHT
SIDE
DK BLU/ RELAY
WHT 87A
30 DK BLU
DK BLU/ 87
ORN
85 BLK/ORN
PNK 86
LOCATED AT FRONT OF VEHICLE
PUMP MOTOR
-
PUR
FROM LEFT SIDE
VEHICLE HEADLAMP
CONNECTOR
BRN WIRES
DO NOT USE ON
DRL VEHICLES
BLK-RIGHT
BLK/WHT-LEFT
(LOW BEAM)
BLK/ORN
S3 SOLENOID
LT BLU
S2 SOLENOID
TO TURN LAMP
BULLET
LT BLU
(GND)
FROM RIGHT SIDE
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
#6 BLK
MTR RLY
#6 RED
12V BATTERY
BRN
P
WHT
LT BLU/WHT
(GND)
BLK YEL
PUR
BLK/ORN
BRN
RED
T
DK BLU (GND)
DK BLU/WHT (GND)
BLK/WHT
P
RED (HIGH)
PUR
T
TO RIGHT SIDE
VEHICLE
HEADLAMPS
BRN/RED
LEFT SIDE PLOW LAMPS
No. 22372
9
May 1998
Electrical Schematic – 12-Pin Vehicle Harness – Revision 1-7
COMPONENTS LOCATED NEAR FRONT OF VEHICLE
PLOW ASSEMBLY
ORN (LOW)
RIGHT SIDE PLOW LAMPS
RED
BRN
TO TURN LAMP
BULLET
GRY
ORN (LOW)
YEL (LOW)
TO LEFT SIDE
VEHICLE
HEADLAMPS
RED (HIGH)
GRN (HIGH)
WHT
DK BLU/ORN
BLK
H
L
DK BLU/ORN-RIGHT
LT BLU/ORN-LEFT
(GROUND)
WHT(HIGH BEAM)
BLK/ORN
S1 SOLENOID
-
+
P
WHT/YEL
#6 BLK/RED
T
P
T
BRN
RED
#6 BLK/RED
#6 BLK
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
RED 87A
87
PNK 86
30 GRN
85 BLK/ORN
LT BLU/
WHT 87A
LT BLU/ 87
ORN
PNK 86
30 LT BLU
87
85 BLK/ORN
86
87A
85
TERMINAL
LOCATIONS
DIODE
REV.
5-7
DRL KIT WIRE
3AG5
PNK
SFE6
RED
IGNITION
RED
LT GRN
BLK/ORN
BRN/RED
LT BLU
WHT/YEL
1
1
2
2
3
3
4
4
5
5
6
6
WHT
*SOLENOID
CONTROL
GRN
BRN
BLK
BLU
RED
*REPRESENTATION
LOCATED UNDER DASH
OF PRINTED
CIRCUIT BOARD
#6 BLK/RED
#6 BLK
LOCATED NEAR BATTERY
BRN
BLK/ORN
GRY
#6 BLK/RED
BLK/ORN
BRN
RED
LEFT
SIDE
RELAY
VEHICLE
HIGH BEAM
RELAY
30
PUR
LT GRN
BLK/WHT
LT BLU/ORN
WHT
L
BRN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
#6 BLK
H
TO PARK LAMP
BULLET
RIGHT
SIDE
DK BLU/ RELAY
WHT 87A
30 DK BLU
DK BLU/ 87
ORN
85 BLK/ORN
PNK 86
LOCATED AT FRONT OF VEHICLE
PUMP MOTOR
M
PUR
FROM LEFT SIDE
VEHICLE HEADLAMP
CONNECTOR
BRN WIRES
DO NOT USE ON
DRL VEHICLES
BLK-RIGHT
BLK/WHT-LEFT
(LOW BEAM)
BLK/ORN
S3 SOLENOID
LT BLU
S2 SOLENOID
TO TURN LAMP
BULLET
LT BLU
(GND)
FROM RIGHT SIDE
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
#6 BLK
BRN/RED
MTR RLY
#6 RED
12V BATTERY
BRN
P
WHT
LT BLU/WHT
(GND)
BLK YEL
PUR
BLK/ORN
BRN
RED
T
DK BLU (GND)
DK BLU/WHT (GND)
BLK/WHT
P
RED (HIGH)
PUR
T
TO RIGHT SIDE
VEHICLE
HEADLAMPS
LEFT SIDE PLOW LAMPS
No. 22372
10
May 1998
7-Pin Harness
PLOW SIDE
T
RED
BLK/ORN
P
BRN
RIGHT SIDE
LAMPS
WHT
BLK/ORN
BLK
H
L
BRN
BLK/ORN
PUR
P
BLK/ORN
BRN
BLK
BLK/ORN
(GROUND)
BLK/ORN
WHT
WHT (HIGH BEAM)
BLK
(LOW BEAM)
LEFT SIDE
LAMPS
P
T
P
T
BLK
BLKORN
WHT
BRN
ORN/BLK
1
2
3
4
5
6
7
8
9
10
11
12
LOCATED AT
FRONT OF VEHICLE
GRY
H
GRY
PUR
BRN
BRN
BLK/ORN
L
7 PIN
(REF: \ PROJ \ EMP \ REV10 \ 13775-90,
" 13775-95)
RED
T
HEADLAMP KIT:
BLK/ORN
RED
BRN
BLK/ORN
RED
13775-90
13775-95
No. 22372
11
May 1998
7-Pin Harness
VEHICLE SIDE
HEADLAMP KIT:
7 PIN
HARNESS TYPE:
A
HEADLAMPS:
DRLs:
PUR
T
P
RED
BLU
L
ORN
NO
REF: \ PROJ \ EMP \ REV10 \ 13775-95
For other headlamp configurations using
the 7-pin harness, use the appropriate
9-pin vehicle schematic.
1
2
3
4
5
6
7
PUR
PUR
H
HB1/HB5
BLK
BLK/ORN
WHT
8
GRY
9
PUR
10
BRN
11
ORN/BLK
12
ORN/BLK
LOCATED AT
FRONT OF VEHICLE
L
BLU
RED
BRN
GRY
H
ORN
ORN 87A
BLK 87
30
YEL
BRN 86
85
BLK/ORN
RED 87A
WHT 87
30
GRN
BRN 86
85
BLK/ORN
P
T
HIGH BEAM
RELAY
YEL (LOW)
GRN (HIGH)
BLU (GND)
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13775-95
No. 22372
LOW BEAM
RELAY
12
May 1998
7-Pin Harness
VEHICLE SIDE
HARNESS TYPE:
A
PUR
DRLs:
RED
BLU
ORN
1
2
3
4
5
6
7
8
9
10
11
12
YES
For \other
configurations
using
REF:
PROJheadlamp
\ EMP \ REV10
\ 13775-90
the 7-pin harness, use the appropriate
9-pin vehicle schematic.
PUR
BROWN WIRES
NOT USED
ON DRL VEHICLES
HB1/HB5
PUR
H
L
PNK
BLK
DRL KIT WIRE
3AG5
PNK
LOCATED UNDER DASH
BLK/ORN
WHT
GRY
PUR
BRN
ORN/BLK
ORN/BLK
LOCATED AT
FRONT OF VEHICLE
ORN
BLU
RED
ORN 87A
BLK 87
30
YEL
PNK 86
85
BLK/ORN
RED 87A
WHT 87
30
GRN
PNK 86
85
BLK/ORN
BRN
GRY
H
7 PIN
HEADLAMPS:
T
P
L
HEADLAMP KIT:
LOW BEAM
RELAY
HIGH BEAM
RELAY
YEL (LOW)
GRN (HIGH)
BLU (GND)
P
T
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13775-95
No. 22372
13
May 1998
9-Pin Harness
HEADLAMP KIT:
PLOW SIDE
REF: \ PROJ \ EMP \ NEW-CONT \ 13606-93,
" 13606-98,
\ PROJ \ EMP \ REV10 \ 13597-97,
" 13607-92,
" 13607-98,
" 13637-92,
VALVE MANIFOLD
" 13637-97,
RED
T
BLK/ORN
BRN
P
RED
BLK/ORN
BRN
P
RIGHT SIDE
LAMPS
WHT
BLK/ORN
BLK
H
L
BLK/ORN
S3(4W)
LT BLU
BRN
BLK/ORN
PUR
T
LT GRN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
WHT (HIGH BEAM)
BLK
(LOW BEAM)
P
T
P
T
No. 22372
BRN
BLK/ORN
RED
GRY
LEFT SIDE
LAMPS
BLK/ORN
BRN
BLK/ORN
H
BLK
BLKORN
WHT
S2(3W)
S1(2W)
WHT/YEL
BLK/ORN
(GROUND)
L
9 PIN
MOTOR
-
M
+
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
#6 BLK/RED
#6 BLK
LOCATED AT
FRONT OF VEHICLE
BRN
BLK/ORN
RED
14
May 1998
9-Pin Harness
VEHICLE SIDE
HEADLAMP KIT:
9 PIN
HARNESS TYPE:
A
HEADLAMPS:
DRLs:
PUR
T
P
PUR
SFE6
PUR
3
4
5
6
WHT/YEL
RED 1
LT GRN 2
ORN/BLK 3
BLK
LT GRN
LT BLU
BLK/ORN
BRN/RED 4
LT BLU 5
WHT
7
8
GRY
9
PUR
10
BRN
11
12
WHT/YEL 6
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
#6 BLK/RED
ORN/BLK
#6 BLK
LOCATED AT
FRONT OF VEHICLE
ORN
BLU
H
RED
BRN
GRY
L
P
T
ORN 87A
BLK 87
30
YEL
BRN 86
85
BLK/ORN
RED 87A
WHT 87
30
GRN
BRN 86
85
BLK/ORN
#6 BLK
BLU (GND)
15
#6 RED
HIGH BEAM
RELAY
YEL (LOW)
13606-98
MTR RLY
BRN/RED
LOW BEAM
RELAY
GRN (HIGH)
No. 22372
RED
IGNITION
12V BATTERY
1
2
NO
REF: \ PROJ \ EMP \ NEW-CONT \ 13606-98
RED
BLU
ORN
H
L
2B/2D
HB1/HB5
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
9-Pin Harness
HEADLAMP KIT: 9 PIN
VEHICLE SIDE
HARNESS TYPE:
HEADLAMPS:
REF: \ PROJ \ EMP \ REV10 \ 13607-98,
L: \ WIREDIAG \ REV10 \ 63103-91.
DRLs:
PUR
T
P
RED
DK BLU
L
ORN
4
5
6
7
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
LT GRN
LT BLU
BLK/ORN
WHT
BRN/RED 4
LT BLU 5
WHT/YEL 6
8
GRY
9
PUR
10
BRN
11
12
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK/RED
#6 BLK
LOCATED AT
FRONT OF VEHICLE
ORN
LT BLU
H
RED
30 YEL
BRN 86
85 BLK/ORN
RED 87A
WHT 87
30 GRN
BRN 86
85 BLK/ORN
BRN
GRY
L
ORN 87A
BLK 87
LOW BEAM
RELAY
MTR RLY
BRN/RED
#6 BLK
#6 RED
HIGH BEAM
RELAY
YEL (LOW)
GRN (HIGH)
P
T
LT BLU (GND)
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13607-98
63103-91
No. 22372
NO
12V BATTERY
1
2
3
PUR
SFE6
WHT/YEL
BLK
2B/2D
2E
HB1
FROM
VEHICLE HEADLAMP
CONNECTOR
DK BLU (GND)
PUR
H
C
16
May 1998
9-Pin Harness
VEHICLE SIDE
PUR
T
P
H
RED
DK BLU
SFE6
1
2
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
RED
IGNITION
LT BLU 5
WHT/YEL 6
LOCATED UNDER DASH
#6 BLK/RED
ORN/BLK
ORN 87A
BLK 87
BRN
LT BLU
RED
86
30
YEL
85 BLK/ORN
RED 87A
WHT 87
30
GRN
BRN 86
85
BLK/ORN
ORN
DK BLU
LOW BEAM
RELAY
YEL (LOW)
BRN
GRY
GRN (HIGH)
LT BLU (GND)
17
#6 RED
HIGH BEAM
RELAY
DK BLU (GND)
13637-97
BRN/RED
#6 BLK
MTR RLY
12V BATTERY
LOCATED NEAR BATTERY
LOCATED AT
FRONT OF VEHICLE
No. 22372
NO
BRN/RED 4
#6 BLK
P
T
HB3/HB4
LF/UF
RED 1
LT GRN 2
ORN/BLK 3
#6 BLK/RED
L
A
REF: \ PROJ \ EMP \ REV10 \ 13637-97
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
H
HARNESS TYPE:
DRLs:
PUR
DK BLU
ORN
9 PIN
HEADLAMPS:
PUR
L
HEADLAMP KIT:
FROM
VEHICLE HEADLAMP
CONNECTOR
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
9-Pin Harness
VEHICLE SIDE
PUR
T
P
9 PIN
HARNESS TYPE:
A
HEADLAMPS:
1A/2A
DRLs:
RED
BLU
ORN
H
L
HEADLAMP KIT:
NO
REF: \ PROJ \ EMP \ REV10 \ 13597-97
RED
PUR
BLU
PUR
SFE6
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
1
2
3
4
5
WHT
6
7
8
GRY
9
PUR
10
BRN
11
12
RED 1
LT GRN 2
ORN/BLK 3
BRN/RED 4
LT BLU 5
WHT/YEL 6
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
#6 BLK/RED
ORN/BLK
#6 BLK
LOCATED AT
FRONT OF VEHICLE
H
BLU
RED
ORN
BLU
H
RED
ORN 87A
BLK 87
30 YEL
BRN 86
85 BLK/ORN
RED 87A
WHT 87
30 GRN
BRN 86
85 BLK/ORN
#6 RED
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13597-97
No. 22372
BRN/RED
#6 BLK
MTR RLY
HIGH BEAM
RELAY
BLU (GND)
GRY
T
LOW BEAM
RELAY
YEL (LOW)
GRN (HIGH)
BRN
L
P
RED
IGNITION
12V BATTERY
H
18
May 1998
9-Pin Harness
VEHICLE SIDE
PUR
T
P
9 PIN
HARNESS TYPE:
A
HEADLAMPS:
DRLs:
DK BLU
L
HEADLAMP KIT:
HB3/HB4
YES
ORN
REF: \ PROJ \ EMP \ REV10 \ 13637-92
RED
H
PUR
DK BLU
4
5
6
7
SFE6
WHT/YEL
BLK
LT BLU
BLK/ORN
WHT
BRN/RED 4
LT BLU 5
WHT/YEL 6
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
#6 BLK/RED
#6 BLK
ORN/BLK
LOCATED AT
FRONT OF VEHICLE
LT BLU
RED
ORN 87A
BLK 87
30 YEL
PNK 86
85 BLK/ORN
RED 87A
WHT 87
30 GRN
PNK 86
85 BLK/ORN
No. 22372
GRN (HIGH)
LT BLU (GND)
19
MTR RLY
BRN/RED
#6 BLK
#6 RED
HIGH BEAM
RELAY
DK BLU (GND)
GRY
13637-92
P
T
LOW BEAM
RELAY
YEL (LOW)
ORN
DK BLU
BRN
L
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
LT GRN
8
GRY
9
PUR
10
BRN
11
12
H
DRL KIT WIRE
3AG5
PNK
12V BATTERY
1
2
3
PNK
PUR
BROWN WIRES
NOT USED
ON DRL VEHICLES
FROM
VEHICLE HEADLAMP
CONNECTOR
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
9-Pin Harness
VEHICLE SIDE
PUR
T
REF: \ PROJ \ EMP \ REV10 \ 13607-92,
L: \ WIREDIAG \ REV10 \ 63103-92.
P
RED
L
ORN
BROWN WIRES
NOT USED
ON DRL VEHICLES
YES
RED
IGNITION
WHT/YEL 6
GRY
PUR
BRN
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
LOCATED AT
FRONT OF VEHICLE
30 YEL
PNK 86
85 BLK/ORN
RED 87A
WHT 87
30 GRN
PNK 86
85 BLK/ORN
BRN
GRY
ORN
LT BLU
RED
ORN 87A
BLK 87
LOW BEAM
RELAY
13607-92
63103-92
20
MTR RLY
BRN/RED
#6 BLK
#6 RED
HIGH BEAM
RELAY
YEL (LOW)
GRN (HIGH)
LT BLU (GND)
P
T
No. 22372
2B/2D
2E
HB1
BRN/RED 4
LT BLU 5
#6 BLK
H
HEADLAMPS:
RED 1
LT GRN 2
ORN/BLK 3
#6 BLK/RED
L
C
DRL KIT WIRE
3AG5
PNK
SFE6
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
HARNESS TYPE:
DRLs:
FROM
VEHICLE HEADLAMP
CONNECTOR
PNK
9 PIN
12V BATTERY
1
2
3
4
5
6
7
8
9
10
11
12
DK BLU (GND)
PUR
DK BLU
PUR
H
HEADLAMP KIT:
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
9-Pin Harness
HEADLAMP KIT: 9 PIN
VEHICLE SIDE
HARNESS TYPE:
PUR
T
P
HEADLAMPS:
DRLs:
REF: \ PROJ \ EMP \ NEW-CONT \ 13606-93
PUR
BROWN WIRES
NOT USED
ON DRL VEHICLES
PNK
DRL KIT WIRE
3AG5
PNK
SFE6
1
2
3
4
5
6
7
8
YES
WHT/YEL
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BRN/RED 4
LT BLU 5
WHT/YEL 6
GRY
9
PUR
10
BRN
11
12
LOCATED UNDER DASH
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK/RED
#6 BLK
ORN 87A
BLK 87
LOCATED AT
FRONT OF VEHICLE
H
RED
BRN
ORN
BLU
GRY
L
YEL
85
BLK/ORN
RED 87A
WHT 87
30
GRN
PNK 86
85
BLK/ORN
PNK
86
30
LOW BEAM
RELAY
T
BRN/RED
#6 BLK
#6 RED
HIGH BEAM
RELAY
YEL (LOW)
GRN (HIGH)
BLU (GND)
P
MTR RLY
12V BATTERY
H
L
PUR
RED
BLU
ORN
A
2B/2D
HB1/HB5
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13606-93
No. 22372
21
May 1998
9-Pin Harness
VEHICLE SIDE
PUR
T
P
PUR
VEHICLE
HEADLAMP
CONNECTOR
PUR
RED
LOW
BLU
BLU
HIGH
COMMON
RIGHT SIDE
VEHICLE FUSE
30
RED
85
TAN
PLOW
LOW BEAM
RELAY
RED
WHT/YEL 6
BAT
TAN
15A
85
AUX
RED 86
RED
LT BLU 5
CB2
BAT
87A
WHT 87
30
AUX
RED 86
CB1
15A
87A
BLK 87
RED
LOCATED UNDER DASH
RED
PLOW
HIGH BEAM
RELAY
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
ORN 87A
LOCATED AT
FRONT OF VEHICLE
TAN 87
BRN 86
BLU
RED
H
RED
YEL
85 BLK/ORN
85 BLK/ORN
BRN/RED
#6 BLK
VEHICLE
LOW BEAM
RELAY
VEHICLE
HIGH BEAM
RELAY
YEL
GRN
BRN
L
ORN
BLU
30
RED 87A
30 GRN
TAN 87
BRN 86
No. 22372
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
#6 BLK
BLU
LOW
HIGH
COMMON
LEFT SIDE
VEHICLE FUSE
22
MTR RLY
#6 RED
PART OF
VEHICLE HEADLAMP
RELAY ASSEMBLY
VEHICLE
HEADLAMP
CONNECTOR
GRY
T
NO
SFE6
#6 BLK/RED
P
1A/2A
(Mitsubishi)
BRN/RED 4
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
3
4
5
6
7
8
GRY
9
PUR
10
BRN
11
12
H
C
DRLs:
+12V
1
2
HARNESS TYPE:
12V BATTERY
H
9 PIN
HEADLAMPS:
RED
BLU
ORN
H
L
HEADLAMP KIT:
+12V
NOTE: All relays are shown
in the de-energized state.
May 1998
12-Pin Harness
PLOW SIDE
HEADLAMP KIT:
12 PIN
For All Vehicles Except:
Nissan w/ and w/o DRLs
Toyota w/DRLs
RED
T
RED
BLK/ORN
P
BRN
WHT
DK BLU/ORN
BLK
H
L
BLK/ORN
BLK/ORN
BLK/ORN
BRN
LT BLU
LT GRN
WHT/YEL
PUR
RIGHT SIDE
LAMPS
P
BRN
T
REF: \ PROJ \ EMP \ REV10 \ 13625-92,
" 13625-97,
VALVE MANIFOLD
" 62914-97,
" 13604-91,
" 13604-98,
S3(4W)
S2(3W)
" 13609-98,
" 13664-92.
S1(2W)
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
DK BLU/ORN - RIGHT
LT BLU/ORN - LEFT
(GROUND)
WHT (HIGH BEAM)
BLK-RIGHT
BLK/WHT-LEFT
(LOW BEAM)
LEFT SIDE
LAMPS
P
BRN
BLK/ORN
T
RED
P
BRN
BLK/ORN
RED
T
No. 22372
23
GRY
BLK/ORN
BRN
H
BLK/WHT
LT BLU/ORN
WHT
BLK/ORN
L
MOTOR
-
M
+
1
2
3
4
5
6
7
8
9
10
11
12
#6 BLK/RED
#6 BLK
LOCATED AT
FRONT OF VEHICLE
May 1998
12-Pin Harness
HEADLAMP KIT: 12 PIN
VEHICLE SIDE
HARNESS TYPE:
HEADLAMPS:
2B/2D
DRLs:
PUR
T
P
B
NO
L
ORN
DK BLU (GND)
PUR
H
PUR
REF: \ PROJ \ EMP \ REV10 \ 13625-92
RED
DK BLU/WHT
SFE6
WHT/YEL
BLK
RED 1
LT GRN 2
ORN/BLK 3
LT GRN
LT BLU
4
BLK/ORN
5
WHT
6
BLK/WHT
7
DK BLU/ORN
8
GRY
9
PUR
10
BRN
11
LT BLU/ORN
12
BLK/ORN
WHT
GRN
BRN/RED 4
LT BLU 5
BLK/WHT
BLK
WHT/YEL 6
DK BLU/WHT 87A
DK BLU/ORN 87
BRN 86
30
85
LOCATED UNDER DASH
DK BLU
BLK/ORN
RIGHT SIDE
RELAY
#6 BLK
ORN
LOCATED AT
FRONT OF VEHICLE
87
BRN 86
30
GRN
85
BLK/ORN
30
LT BLU
85
BLK/ORN
VEHICLE
HIGH BEAM
RELAY
LT BLU/WHT
RED
LT BLU/WHT 87A
LT BLU/ORN 87
BRN 86
T
#6 RED
LEFT SIDE
RELAY
YEL (LOW)
GRN (HIGH)
LT BLU (GND)
13625-92
No. 22372
BRN/RED
#6 BLK
MTR RLY
ORN
BRN
GRY
P
YEL
BRN
RED 87A
L
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK/RED
H
RED
IGNITION
12V BATTERY
1
2
3
FROM
VEHICLE HEADLAMP
CONNECTOR
24
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
12-Pin Harness
HEADLAMP KIT:
VEHICLE SIDE
HARNESS TYPE:
A
(combines 2 harnesses)
REF: \ PROJ \ EMP \ REV10 \ 13625-97
PUR
PUR
RED
1
2
3
4
5
6
WHT/YEL
BLK/WHT
BLK
BLU 87A
DK BLU/ORN 87
BRN 86
BRN/RED 4
LT BLU 5
WHT/YEL 6
LOCATED UNDER DASH
30 PUR
85 BLK/ORN
RIGHT SIDE
RELAY
BRN
BRN
GRY
ORN
BLU
RED
YEL
ORN
LOCATED AT
FRONT OF VEHICLE
P
T
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK
H
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
#6 BLK/RED
L
NO
SFE6
BLK/ORN
WHT
GRN
WHT
BLK/WHT
7
DK BLU/ORN
8
GRY
9
PUR
10
BRN
11
LT BLU/ORN
12
DRLs:
FROM
VEHICLE HEADLAMP
CONNECTOR
BLK
LT GRN
LT BLU
BLK/ORN
HB1
BLU
BLU
PUR
L
BLU (GND)
PUR
BLU
ORN
BLU
H
HEADLAMPS:
RED 87A
87
BRN 86
BLU 87A
LT BLU/ORN 87
BRN 86
30 GRN
85 BLK/ORN
VEHICLE
HIGH BEAM
RELAY
BRN/RED
#6 BLK
MTR RLY
#6 RED
12V BATTERY
T
P
12 PIN
30 BLU
85 BLK/ORN
LEFT SIDE
RELAY
YEL (LOW)
GRN (HIGH)
BLU (GND)
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
13625-97
No. 22372
25
May 1998
12-Pin Harness
VEHICLE SIDE
REF: \ PROJ \ EMP \ REV10 \ 62914-97
PUR
T
P
L
ORN
DK BLU/WHT
H
DK BLU
RED/WHT
DK BLU (GND)
ORN (LOW)
GRN/WHT (HIGH)
DK BLU/WHT 87A
BLK 87
PNK 86
FROM
VEHICLE HEADLAMP
CONNECTORS
30
DK BLU
85
BLK/ORN
RED 1
LT GRN 2
ORN/BLK 3
RIGHT SIDE
LOW BEAM
RELAY
PNK
PNK
LT BLU
LOCATED UNDER DASH
30
GRN/WHT
85
BLK/ORN
RED 87A
LT BLU/WHT 87A
BLK/WHT 87
30
RIGHT SIDE
HIGH BEAM
RELAY
GRN
BLK/ORN
30
LT BLU
85
TAN
PNK
85
LOCATED NEAR BATTERY
LEFT SIDE
HIGH BEAM
RELAY
BRN/RED
#6 BLK
MTR RLY
#6 RED
LEFT SIDE
LOW BEAM
RELAY
YEL (LOW)
LT BLU (GND)
BRN
GRY
LT BLU/WHT
YEL
BRN/RED 4
LT BLU 5
#6 BLK/RED
ORN/BLK
LT BLU/ORN 87
RED
RED
IGNITION
12V BATTERY
LT BLU
PNK 86
PNK 86
No. 22372
HB3/HB4
DRLs:
YES
(Automatic, DRL kit not required)
SFE6
WHT
LT BLU
RED/WHT 87A
DK BLU/ORN 87
PNK 86
62914-97
HEADLAMPS:
WHT/YEL 6
LOCATED AT
FRONT OF VEHICLE
L
D
PUR
BLK/ORN
PUR
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
#6 BLK/RED
#6 BLK
H
12 PIN
HARNESS TYPE:
DK BLU (GND)
BROWN WIRES
NOT USED
ON DRL VEHICLES
1
2
3
4
5
6
7
8
9
10
11
12
HEADLAMP KIT:
GRN (HIGH)
LT BLU (GND)
P
T
26
FROM
VEHICLE HEADLAMP
CONNECTORS
NOTE: All relays are shown
in the de-energized state.
May 1998
12-Pin Harness
VEHICLE SIDE
HEADLAMP KIT:
12 PIN
HARNESS TYPE:
B
HEADLAMPS:
REF: \ PROJ \ EMP \ REV10 \ 13604-91
DRLs:
RED
DK BLU/WHT
ORN
PNK
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
BLK/ORN
GRN
BRN/RED 4
LT BLU 5
WHT/YEL 6
DK BLU/WHT 87A
DK BLU/ORN 87
PNK 86
30
85
DK BLU
BLK/ORN
LOCATED UNDER DASH
RIGHT SIDE
RELAY
LOCATED NEAR BATTERY
PNK
#6 BLK/RED
ORN/BLK
RED 87A
87
LOCATED AT
FRONT OF VEHICLE
BRN
GRY
ORN
LT BLU/WHT
RED
GRN
85
BLK/ORN
30
LT BLU
85
BLK/ORN
HIGH BEAM
RELAY
BRN/RED
#6 BLK
MTR RLY
#6 RED
YEL
ORN
PNK 86
30
LT BLU/WHT 87A
LT BLU/ORN 87
PNK 86
P
T
LEFT SIDE
RELAY
YEL (LOW)
GRN (HIGH)
LT BLU (GND)
13604-91
No. 22372
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
PNK
WHT
#6 BLK/RED
#6 BLK
H
DRL KIT WIRE
3AG5
PNK
SFE6
BLK/WHT
BLK
1
2
3
4
5
6
7
8
9
10
11
12
FROM
VEHICLE HEADLAMP
CONNECTOR
PUR
BROWN WIRES
NOT USED
ON DRL VEHICLES
YES
12V BATTERY
L
DK BLU (GND)
PUR
H
L
2E
(Early GM applications used
two harnesses spliced together)
PUR
T
P
2B/2D
27
NOTE: All relays are shown
in the de-energized state.
FROM
VEHICLE HEADLAMP
CONNECTOR
May 1998
12-Pin Harness
VEHICLE SIDE
HARNESS TYPE:
PUR
T
P
HEADLAMP KIT: 12 PIN
HEADLAMPS:
HB3 /HB4
DRLs:
ORN
DK BLU/WHT
L
B
YES
BROWN WIRES
NOT USED
ON DRL VEHICLES
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
PNK 86
30
85
BLK/ORN
LOCATED UNDER DASH
HIGH BEAM
RELAY
LOCATED NEAR BATTERY
PNK
RED 87A
ORN
YEL
87
RED
LT BLU/WHT
MTR RLY
ORN/BLK
PNK
86
DK BLU/ORN 87
PNK 86
30
GRN
85
BLK/ORN
30
DK BLU
85
BLK/ORN
DK BLU/WHT
ORN
VEHICLE
HIGH BEAM
RELAY
LOW BEAM
RELAY
YEL (LOW)
DK BLU (GND)
BRN
GRY
No. 22372
LT BLU
GRN (HIGH)
LT BLU (GND)
P
T
28
BRN/RED
#6 BLK
#6 RED
12V BATTERY
LT BLU/WHT 87A
LT BLU/ORN 87
DK BLU/WHT 87A
13604-98
LT BLU 5
#6 BLK/RED
LOCATED AT
FRONT OF VEHICLE
L
BRN/RED 4
WHT/YEL 6
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
#6 BLK/RED
#6 BLK
H
RED
IGNITION
RED 1
LT GRN 2
ORN/BLK 3
BLK/ORN
WHT
GRN
PNK
4
5
6
7
8
9
10
11
12
DRL KIT WIRE
3AG5
PNK
SFE6
BLK/WHT
BLK
1
2
3
PNK
PUR
DK BLU/WHT
RED
H
PUR
REF: \ PROJ \ EMP \ REV10 \ 13604-98
NOTE: All relays are shown
in the de-energized state.
FROM
VEHICLE HEADLAMP
CONNECTORS
May 1998
12-Pin Harness
VEHICLE SIDE
PUR
T
P
12 PIN
HARNESS TYPE:
B
HEADLAMPS:
LF/UF
DRLs:
ORN
DK BLU
L
HEADLAMP KIT:
YES
REF: \ PROJ \ EMP \ REV10 \ 13609-98
PUR
DK BLU
RED
BROWN WIRES
NOT USED
ON DRL VEHICLES
RED 1
LT GRN 2
ORN/BLK 3
BLK/ORN
WHT
BRN/RED 4
GRN
LT BLU 5
WHT/YEL 6
LT BLU 87A
LT BLU/ORN 87
PNK 86
30
85
LT BLU
BLK/ORN
LOCATED UNDER DASH
HIGH BEAM
RELAY
#6 BLK
RED 87A
87
ORN
YEL
LOCATED AT
FRONT OF VEHICLE
RED
LT BLU
PNK
86
DK BLU 87A
DK BLU/ORN 87
PNK 86
30
GRN
85
BLK/ORN
30
DK BLU
13609-98
No. 22372
VEHICLE
HIGH BEAM
RELAY
MTR RLY
BRN/RED
#6 BLK
#6 RED
LOW BEAM
RELAY
85
DK BLU
ORN
YEL (LOW)
DK BLU (GND)
BRN
GRY
L
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
#6 BLK/RED
H
RED
IGNITION
12V BATTERY
4
5
6
7
8
9
10
11
12
DRL KIT WIRE
3AG5
PNK
SFE6
BLK/WHT
BLK
1
2
3
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
PNK
PUR
H
P
T
GRN (HIGH)
LT BLU (GND)
29
FROM
VEHICLE HEADLAMP
CONNECTORS
NOTE: All relays are shown
in the de-energized state.
May 1998
12-Pin Harness
HEADLAMP KIT:
12 PIN
Nissan w/ and w/o DRLs
Toyota w/DRLs
PLOW SIDE
REF: \ PROJ \ EMP \ REV10 \ 13600-98
RED
T
P
BLK/ORN
BRN
VALVE MANIFOLD
BLK/ORN
BLK/ORN
BRN
DK BLU/ORN
WHT
BLK
H
L
S3(4W)
LT BLU
LT GRN
WHT/YEL
PUR
T
P
BRN
RIGHT SIDE
LAMPS
BLK/ORN
RED
S1(2W)
WHT (GROUND)
DK BLU/ORN - RIGHT
LT BLU/ORN - LEFT
(HIGH BEAM)
BLK-RIGHT
BLK/WHT-LEFT
(LOW BEAM)
LEFT SIDE
LAMPS
P
T
P
T
No. 22372
BRN
GRY
BLK/ORN
WHT
LT BLU/ORN
BRN
H
BLK/WHT
BLK/ORN
L
MOTOR
-
M
S2(3W)
+
WHT/YEL
1
BLK
2
LT GRN
3
LT BLU
4
BLK/ORN
5
WHT
6
BLK/WHT
7
DK BLU/ORN
8
GRY
9
PUR
10
BRN
11
LT BLU/ORN
12
#6 BLK/RED
#6 BLK
LOCATED AT
FRONT OF VEHICLE
BLK/ORN
RED
BRN
BLK/ORN
RED
30
May 1998
12-Pin Harness
VEHICLE SIDE
HEADLAMP KIT:
HARNESS TYPE:
A
(combines 2 harnesses)
REF: \ PROJ \ EMP \ REV10 \ 13600-98
HEADLAMPS:
PUR
T
YEL (LOW)
GRN (HIGH)
BLU (GND)
PUR
YEL
GRN
L
BROWN WIRES
NOT USED
ON DRL VEHICLES
PNK
PNK 86
85
BLK/ORN
(NOT USED)
PNK
WHT
BLU
BRN
GRY
ORN
BLU
RED
ORN 87A
LT BLU/ORN 87
PNK 86
RED 87A
LT BLU/ORN 87
TAN 86
30
85
RIGHT SIDE
LOW BEAM
RELAY
BLU
30
YEL
85
BLK/ORN
30
GRN
85
TAN
BRN/RED 4
LT BLU 5
LOCATED NEAR BATTERY
#6 BLK/RED
ORN/BLK
LEFT SIDE
LOW BEAM
RELAY
BRN/RED
#6 BLK
MTR RLY
#6 RED
LEFT SIDE
HIGH BEAM
RELAY
P
YEL (LOW)
GRN (HIGH)
T
BLU (GND)
13600-98
No. 22372
RED 1
LT GRN 2
ORN/BLK 3
LOCATED UNDER DASH
RIGHT SIDE
HIGH BEAM
RELAY
BLK/ORN
RED
IGNITION
WHT/YEL 6
BLK/ORN
PUR
BLK/ ORN
PNK
30
PNK 86
LOCATED AT
FRONT OF VEHICLE
H
ORN 87A
BLK 87
RED 87A
DK BLU/ORN 87
#6 BLK/RED
#6 BLK
L
PNK
BLK/WHT
PUR
PUR
1
2
3
4
5
6
7
8
9
10
11
12
DRL KIT WIRE
3AG5
PNK
SFE6
BLK/ORN
WHT/YEL
BLK
LT GRN
LT BLU
BLK/ORN
WHT
BLK/WHT
DK BLU/ORN
GRY
PUR
BRN
LT BLU/ORN
DRLs: YES/NO
(Nissan w/ and w/o DRLs;
Toyota w/DRLs)
FROM
VEHICLE HEADLAMP
CONNECTOR
BLU
RED
BLU
ORN
H
2B/2D
HB1
12V BATTERY
P
12 PIN
31
FROM
VEHICLE HEADLAMP
CONNECTOR
NOTE: All relays are shown
in the de-energized state.
May 1998
Fisher Engineering
P.O. Box 529
Rockland, ME 04841
Copyright © 1998 Douglas Dynamics. L.L.C. All rights reserved. This material may not be reproduced or copied, in whole or in part, in any printed, mechanical, electronic, film or other distribution
and storage media, without the written consent of Fisher Engineering. Authorization to photocopy items for internal or personal use by Fisher Engineering outlets is granted.
Fisher Engineering reserves the right under its product improvement policy to change construction or design details and furnish equipment when so altered without reference to illustrations or
specifications used herein. Fisher Engineering and the vehicle manufacturer may require and/or recommend optional equipment for snow removal. This product is manufactured under the
following patents: 4,280,062, 4,999,935, 5,353,530, 5,420,480 and RE35700, and other patents pending. Fisher Engineering offers a limited warranty on all snowplows and accessories. See
separately printed page for this important information. The following are registered® and unregistered™ trademarks of Douglas Dynamics, L.L.C.: FISHER®, Minute Mount®
Printed in USA
No. 22372
32
May 1998