Technical Data Sheet
Screen Degreaser No. 3
Screen Degreaser Concentrate No. 33
Degreaser solutions that remove dirt, dust and oils from all fabrics, new and used.
Degreasing should be considered a first step in stencil making, as it greatly reduces the risk of stencil-making failure,
extends on-press stencil longevity, and alleviates pin holing. No. 3 is ready-to-use – no mixing. Degreases effectively
in hard water. Rinses clean with hot or cold water. Non-caustic-will not harm frames, fabric, or adhesives on stretch
and glue frames. Recommended for use with all Ulano stencil systems.
INSTRUCTIONS:
If using No. 33, mix ten parts water to one part No. 33.
Apply No. 3 or diluted No. 33 to a wet screen from both sides with a wet, soft, long-bristle nylon brush.
Continue brushing until light foam develops.
Let the screen stand a few minutes until the foam subsides.
Rinse the screen thoroughly from both sides, including the inside edge of the frame and the frame corners, with hot or
cold water.
HEALTH AND SAFETY INFORMATION:
After ink removal, spray both sides of the screen with water and apply No. 3 or No. 33 as in degreasing (above). Rinse
with tap water. Degreasing helps remove oily ink residues, wash-up solvents and makes the stencil more receptive to
water-borne removal chemicals.
Screen Degreaser Liquid No. 3 and Screen Degreaser No. 33 may be irritating upon prolonged contact with the skin
or eyes.
FIRST AID: In case of contact with the eyes or skin, flush immediately with water. If irritation develops, contact a
physician.
No. 3
PACKAGING:
1 quart=946 ml
1 gallon=3.785 liters
5 gallons=18.925 liters 50 gallons=189.25 liters
No. 33
PACKAGING:
1 quart=946 ml
1 gallon=3.785 liters
5 gallons=18.925 liters 50 gallons=189.25 liters
Ulano Corporation, 110Third Avenue, Brooklyn, NY 11217(USA). Tel: +1 718 237 4700 Fax: +1 718 802 1119 e-mail: [email protected]
Ulano International (V.I.), Inc., CH-8952 Schlieren-Zurich (Switzerland) Tel: +41 1 755 44 77 Fax + 41 1 773 16 06 e-mail: [email protected]
Screen Degreaser No 3 and 33 Tech Data Sheet 2003.doc
10/27/2005